Manuals / Patterson-Kelley / Household Appliance / Boiler

Patterson-Kelley MACH-05 manual Display Panel

Models: MACH-05

1 59

Download 59 pages 32.78 Kb

Page 48

6.2.3 Display Panel

MACH® Series Gas-Fired Boiler	Parts and Technical Support

6.2.3 Display Panel

			3
			2
	Mark	Description
	1	Circuit Breaker
	2	Air Pressure Switch
	3	Fastening Clip	4
	4	Display Panel	8
	5	On/Off Switch	8
	5	On/Off Switch
	6	Pressure Temperature Gauge
	7	Panel Sheet Metal
	8	Stack Pressure Switch
			7

1

6

5

Page 44

Image 48

Patterson-Kelley MACH-05 manual Display Panel

Contents

PATTERSON-KELLEY MACH SERIES BOILER GAS-FIREDBOILERMACH-05 MACH Series Gas-FiredBoiler 5.0 MAINTENANCE 4.0 OPERATION2.0 SAFETY 3.0 INSTALLATION7.0 LIMITED WARRANTY 8.0 APPENDIXWhat to do if you smell gas 2.0SAFETY 1.0 INTRODUCTION2.5.2 Burn, Fire, and Explosion Hazards 2.5.1 Electrical Hazards2.4SAFETY LABELS 2.5SAFETY PRECAUTIONS2.5.3 Crush Hazards 2.5.4 Chemical Hazards2.5.5Pressure Hazards 2.5.6Slip, Fall HazardsImproper use may result in fire or injury Improper use may result in fire or injury3.0INSTALLATION 3.1.2 Storage Prior to Installation3.3.2 Placement 3.1.1 Initial Inspection3.3.3 Clearances 3.5.1 Air Inlet Requirements 3.6.1 Barometric Damper 3.6.2 Flue Connection3.6.3 Required Clearances 3.6.4 Vent Terminations 3.6.5 Venting for Multiple Boilers3.6.6 Sealed Combustion Air/Venting System 3.6.7Removing an Existing Boiler3.6.8 Intake/Exhaust Layout Basic Air Inlet/Vent Configurations Sidewall Inlet, Roof VentRoof Inlet and Vent Sidewall Inlet and Vent3.6.12 Intake Duct Terminations 3.6.9 Intake Duct Materials and Sizes3.6.10 Sealing the Intake Duct 3.6.11 Intake Duct Connection to Boiler3.6.13 Vent Elbows tape on gas line threadsIntake Termination Details 3.7GAS PIPING3.7.1 Gas Supply Piping by Installer 3.8.1 Piping Design3.8.2 Boiler Inlet and Outlet Connections Piping With Refrigeration MachinesPiping With Air Handling Units 3.8.3 Boiler Water Piping by Installer 3.8.4 Flushing and Filling3.9.1 Inspection 3.11.1Test of Ignition Safety System MACH C300 & C450MACH C750, C900 & C1050 3.11.4 Test of Gas Pressure Switch Low Gas Pressure SwitchHigh Gas Pressure Switch 3.11.2 Test of Low Water Cut-out3.12.1 Operating Temperature Controller Internal Setpoint Domestic Priority Internal Setpoint Domestic PriorityParameter ValueOutdoor Air Reset optional OUTDOOR AIR vs BOILER SETPOINTParameter Value3.12.2 Gas Pressure Adjustment Analog Input to Adjust SetpointAnalog Input to Control Firing Rate 3.12.3 Air Flow Adjustments 3.12.4 Gas Valve Setup and AdjustmentMACH C300 & C450 Boiler Test ModeAdjustment PageMACH C750, C900 & C450 4.2.1 Lighting Procedures 4.2.2 Normal Shut Down Procedures4.0OPERATION 4.1.1 Control Panel Front4.2.3 Emergency Shut-Off 750,000712,500 712,5005.0MAINTENANCE 5.1.2 Weekly5.1.3 Monthly During Operation 5.1.1 Daily5.1.4 Semi-Annuallyevery 6 months 5.1.5 AnnuallyThe Loss of Power 5.5TROUBLESHOOTING5.4SEQUENCE OF OPERATION Air Switch Closed High Water TemperatureLoss of Water Level Low Gas Pressure5.5.1 Manual Reset Service Codes CodeLockout Description5.5.2 Auto-resetService Codes If any “Manual Reset” limit device tripsDO NOT 6.0 PARTS/TECHNICAL SUPPORT MACH Series Gas-FiredBoilerParts and Technical Support 6.1WIRING DIAGRAMS Terminal NumberLabel DescriptionTerminal Number LabelDescription DO NOT ENERGIZE6.1.2 Wiring Series C-300 MACH Series Gas-FiredBoilerParts and Technical Support 6.1.3 Wiring Series C-450 MACH Series Gas-FiredBoilerParts and Technical Support 6.1.4 Wiring Series C-750/900/1050 MACH Series Gas-FiredBoilerParts and Technical Support 6.2.1 Main Assembly MACH Series 300/450MACH Series 750/900/1050 6.2.2 Control Panel MarkDescription 6.2.3 Display Panel 6.2.4 C-300/450Heat Engine Mark Description6.2.5 C-750/900/1050Heat Engine 6.2.6 C-300Boiler Gas Train MarkDescription 6.2.7 C-450Boiler Gas Train 6.2.8 C-750/900/1050Boiler Gas Train MarkDescription 7.0 LIMITED WARRANTY WARRANTYREMEDY EXCLUSIONSTHIRD PARTY WARRANTIES SEVERABILITYNO OTHER WARRANTIES 8.0 APPENDIX DateHi/Low-Fire Stack TempParameter Settings for MCBA Controls Description Manual fanspeed