Manuals / Toshiba / Household Appliance / Air Conditioner

Toshiba RAV-SM1104BT-TR E03 error Master indoor unit, F29 error, P31 error Follower indoor unit

Models: RAV-SM454MUT-TR RAV-SM564CT-E RAV-SM564BT-E RAV-SM564MUT-E RAV-SM564BT-TR RAV-SM564MUT-TR RAV-SM804BT-TR RAV-SM804BT-E RAV-SM1104BT-TR RAV-SM1404BT-TR RAV-SM1104BT-E RAV-SM1404BT-E RAV-SM404MUT-TR RAV-SM454MUT-E

1 120

Download 120 pages 15 Kb

Page 61

[E03 error] (Master indoor unit)

[E03 error] (Master indoor unit)

[E03 error] is detected when the indoor unit cannot receive a signal from the wired remote controller (also central controller).

Check A and B remote controllers and communication lines of the central control system U3 and U4.

As communication is impossible, this check code [E03] is not displayed on the wired remote controller and the central controller.

[E01] is displayed on the wired remote controller and [C06 error] is displayed on the central controller. If these check codes generate during operation, the air conditioner stops.

[F29 error]

This check code indicates a detection error of IC10 non-volatile memory (EEPROM) on the indoor unit P.C. board, which generated during operation of the air conditioner. Replace the service P.C. board.

∗When EEPROM was not inserted when power supply turned on or when the EEPROM data read/write operation is impossible at all, the automatic address mode is repeated. In this time, [97 error] is displayed on the central controller.

	(Approx.			(Approx.
3 minutes)				1 minute)
(Power ON)			[SET] is displayed on				[SETTING]		LED (D002) on indoor unit		Reboot
			[SET] is displayed on				[SETTING]		P.C. board flashes with		Reboot
			wired remote controller.				goes off.		P.C. board flashes with		(Reset)
			wired remote controller.				goes off.		1Hz for approx. 10 seconds.		(Reset)
									1Hz for approx. 10 seconds.

(Repetition)

[P31 error] (Follower indoor unit)

When the master unit of a group operation detected [E03], [L03], [L07] or [L08] error, the follower unit of the group operation detects [P31 error] and then the unit stops.

There is no display of the check code or alarm history of the wired remote controller. (In this model, the mode enters in automatic address set mode when the header unit detected [L03], [L07] or [L08] error.)

– 61 –

Image 61

Toshiba RAV-SM1104BT-TR, RAV-SM454MUT-E E03 error Master indoor unit, F29 error, P31 error Follower indoor unit, 61

Contents

R410A SERVICE MANUAL SPLIT TYPEINDOOR UNIT <DIGITAL INVERTER> CONTENTS 6. TROUBLESHOOTING Generic Denomination: Air Conditioner Original instruction– 4 – Work undertaken – 5 –Protective gear worn IndicationBURST HAZARD Warning Indications on the Air Conditioner Unit– 6 – Warning indicationDENGER Precaution for Safety– 7 – – 8 – – 9 – – 10 – Relocation Explanations given to userDeclaration of Conformity – 11 –Specifications 1 Copper pipe <Piping> New Refrigerant R410AFlare nut 2JointGeneral tools Conventional tools can be used 4.Tools– 14 – 1. AIR DUCTING WORK 1-1.Static Pressure CharacteristicsConcealed Duct type – 15 –Fig. 7 SM140 type Round duct Fig. 5 SM110 type Round ductFig. 6 SM110 type Square duct Fig. 8 SM140 type Square duct2. CONSTRUCTION VIEWS EXTERNAL VIEWS Space required for installation and servicing2-1.Compact 4-wayCassette Type – 17 –SM56 type – 18 –SM80 type SM110 typeModel name – 19 –SM56 type Ø12.73-1.Indoor Unit 3. WIRING DIAGRAM3-1-1.Compact 4-wayCassette Type – 20 –– 21 – 3-1-2.Concealed Duct Type– 22 – 3-1-3.Ceiling TypeSpecifications SpecificationsSpecifications – 23 –Central remote controller Wired Simple heder remote controller Max. 2 units– 24 – Indoor unit– 25 – Wireless remote controllerIndoor unit #1 Heder ∗ “1:1 model” connection interface OptionWired Simple heder remote controller Wireless remote controllerCentral remote controller – 26 –Outline of specifications 5-2.Control SpecificationsItem Remarks– 28 – Outline of specificationsItem Remarks– 29 – Outline of specificationsItem RemarksItem – 30 –Remarks Ceiling type– 31 – Outline of specificationsItem RemarksSetup at shipment Outline of specifications– 32 – Item– 33 – Outline of specificationsItem RemarksAlarm Outline of specifications– 34 – Item<In case of wired remote controller> Outline of specifications– 35 – Item4, 5, Outline of specifications– 36 – Item– 37 – Outline of specificationsItem Remarks“8. SETUP AT LOCAL Outline of specifications– 38 – ItemRemarks Outline of specifications– 40 – 5-3.Indoor Print Circuit BoardSpecifications Connector– 41 – Function– 42 – <Wired remote controller type>Trouble Confirmation of check code displayTrouble When wireless remote controller is connectedConfirmation of lamp display Check defective position and parts– 44 – Outline of judgmentLamp indication – 45 –Check code – 46 – Others Other than Check CodeLamp indication Check code6-2.Check Code List Indoor Operation of diagnostic function Error mode detected by indoor unit– 48 – Judgment and measures– 49 – Error mode detected by outdoor unit– 50 – Operation of diagnostic functionCheck Status ofPage E09 error Check code E01 error– 52 – E10 error E04 errorE08, L03, L07, L08 error E18 errorL09 error – 54 –L30 error L20 errorP30 error Central controller – 55 –F10 error P10 error– 57 – P12 errorCheck by tester P19 error– 58 – F01 error F02 error– 59 – – 60 – C06 error 1:1 model connection interfaceF29 error E03 error Master indoor unitP31 error Follower indoor unit – 61 –TA, TC, TCJ, TE,TS, TO sensor TA, TC, TCJ, TE, TS, TO sensorTD, TL sensor Resistance value kΩ– 63 – Winding Resistance of Fan MotorPage Contents 1 Setting data read out from EEPROM– 65 – CODE No. required at least3 6 5 <Fig. 2 EEPROM layout diagram>MCC-1402 – 66 –Setting data Setting dataSetting data TableWired remote controller 8-1-1.Test Run Setup on Remote Controller8-1.Indoor Unit – 68 –4, 5, Procedure<Ceiling Type> – 69 –Preparation in advance 3 4 5Practical operation 8-1-3.LED Display on Indoor P.C. Board 1.D002 Red4 5 2 8-1-4.Function Selection Setup1 2 3 4 5 6 END – 71 –Item No. DN table Selection of function – 72 –Description At shipmentItem – 73 –Description At shipment<Wireless remote controller> <Wired remote controller>Wireless remote controller – 74 –nCalling of sensor temperature display 8-1-6.Monitor Function of Remote Controller1 2 – 75 –– 76 – REQUIREMENT– 77 – nIndoor unit power-ONsequence– 78 – 8-2.Setup at Local Site / Others5.P.C. Board Switch SW01 Setup 4.Wiring Specifications1 2 3 <Procedure> Perform setup while the unit stops3 1 4 – 80 –– 81 – – 82 – 9-1.Address Setup– 83 – 9-2-1.System configurationExample – 84 –– 85 – simultaneously from the remote controllerChange is necessary 1 2 3 4 5 6 7 8 9 10 11 END 3, 6, 9 4, 7,1 2 END 1. Detachment 10-1.Compact 4-WayCassette Type2.Attachment 1. Detachment Procedure2.Attachment 1. Detachment– 90 – Procedure1. Detachment 2.Attachment– 91 – Procedure1.Detachment 2.Attachment– 92 – Procedure1.Detachment 2.Attachment– 93 – Procedure1. Detachment 2. Attachment– 94 – Procedure9Fan motor 1. Detachment 2. Attachment– 95 – Procedure10Drain pan 1. Detachment 2. Attachment1 Recover refrigerant gas Procedure<Details of sensor lead wire drawing> – 96 –10-2.Concealed Duct Type Procedure– 97 – Part name– 98 – ProcedurePart name Remarks– 99 – ProcedurePart name Remarks10-3.Ceiling Type Procedure– 100 – No. Part name– 101 – ProcedurePart name Remarks– 102 – ProcedurePart name Remarks103 ProcedurePart name Remarks– 104 – 11-1.Compact 4-wayCassette TypeLocation 105Part No DescriptionLocation – 106 –Part No Description– 107 – Electric partsLocation Model name240 241 242 229 216 227 11-2.Concealed Duct Type203, 902, 204, 206,Location 109Part No Description235901, 902, 903 222 223 220 232 234 224 230 221 228 229 219 202 203218 212 – 110 –Location – 111 –Description Model name211 237221 202 203, 901, 902, 903 224 236 225 222 230, 232 223234 215 214 213 212Location – 113 –Part No Description– 114 – Electric partsLocation Model name RAV-SM11-3.Ceiling Type Part No – 116 –Description Model name RAV-SMPart No – 117 –Description Model name RAV-SM– 118 – Electric partsLocation Model nameCheck of Concentration Limit WARNINGS ON REFRIGERANT LEAKAGETOSHIBA CARRIER CORPORATION