PREPARING TO USE YOUR GRILL
WHAT IS A LEAK CHECK?
The fuel system in your grill features many connections and fittings. A leak check is a reliable way to make sure that no gas is escaping from any of the connections or fittings.
Although all
PARTIAL DISASSEMBLY OF YOUR GRILL FOR A LEAK CHECK
In order to do the leak check, you need to have access to the gas valves, which will require some simple grill disassembly.
Confirm that Grill Is Off
A)Turn gas supply off at source.
B)Check that ALL burner control knobs are in the off (
) position (1). Control knobs are shipped in the off (
) position, but you should check to be sure that they are turned off. Check by pushing control knobs in and turning them clockwise. If they do not turn, they are off. If they do turn, continue turning them clockwise until they stop; then they are off. If your grill has a side burner, make sure the side burner control knob is turned off.
Remove Control Panel
You will need: A Phillips screwdriver.
A)Disconnect the two wires from the igniter button located on the underside of the control panel (2). NOTE: Pull from terminals at ends of wires.
B)Remove control knobs (3).
C)Remove the screws from the front of the control panel with a Phillips screwdriver (4).
D)Carefully lift control panel up and then pull forward away from frame (5).
Your grill is now ready for a leak check. Proceed to
“CHECKING FOR GAS LEAKS.”
Safety must be considered when you are | 1 |
deciding where to place and operate your |
|
grill. Be sure to read the following warnings |
|
before installing or using your grill. | 2 |
|
WARNINGS:
m Only use this grill outdoors in a well- ventilated area. Do not use in a garage, building, breezeway or any other enclosed area.
mYour Weber® gas grill shall not be
used beneath overhead combustible |
|
|
construction. |
|
|
m Your Weber® gas grill is not intended |
|
|
to be installed in or on recreational |
|
|
vehicles and/or boats. |
|
|
m Do not use the grill within 24 inches of |
|
|
combustible materials. This includes |
|
|
the top, bottom, back or sides of the |
|
|
grill. |
|
|
m Keep the cooking area clear of |
|
|
flammable vapors and liquids such |
|
|
as gasoline, alcohol, etc., and | 3 | 4 |
combustible materials. |
mKeep ventilation openings for cylinder enclosure free and clear from debris.
m The entire cookbox gets hot when in use. Do not touch.
m Do not move the Weber® gas grill when operating or while grill is hot.
5
14WWW.WEBER.COM®
