Polaris P2000i, P1000i manual Safety

Page 16

SAFETY

Safety Labels and Locations

Improper Generator use can result in SEVERE INJURY or DEATH. Read the OWNER’S MANUAL. Follow all Instructions and Warnings.

Petrol is flammable and explosive. Severe burns can result. ALWAYS stop the engine and let cool down before refueling. ALWAYS check for fuel leaks and wipe up any spills. ALWAYS turn the fuel to OFF when not in use. NEVER handle petrol indoors. NEVER overfill the fuel tank. Generator exhaust contains poisonous Carbon Monoxide (CO) vapors. ALWAYS operate in a well-ventilated area. NEVER operate in a home, garage, enclosed area or near windows, doors, or people. NEVER operate near flammable objects.

Electrocution can result from using generator in rain, snow, near water, with wet hands, or with improper connections. ALWAYS keep generator and surrounding area dry. NEVER connect generator to any building without electrical-isolation protection that meets applicable codes and regulations.

15

Image 16

Contents Polaris Power Table of Contents Introduction WelcomeIntended Use Safety Precautions Signal Words and Safety Terms Alcohol or Drug USEIdentification Numbers and Locations P1000iP2000iSafety Safety Warnings and PrecautionsGeneral Before and During OperationFire Safety Operator Safety Fuel Safety Carbon Monoxide Safety Electrical Safety Extension Cord Information Equipment ModificationsSafety Labels and Locations Carbon Monoxide WarningOutdoor Use only Danger Label Hot Exhaust CautionSafety Controls and Features Generator ComponentsControl Panel Components P1000i P2000iEngine Fuel Switch Choke LeverFuel Tank Cap Vent Lever Starter Recoil GripSmart Throttle Switch DC Receptacle and FuseGround Terminal Indicator PanelAC Receptacles Overload Protector Reset Switch Parallel ReceptaclesFirst USE Instructions Adding Engine OilFuel Recommendation Adding Fuel Pre-Operation Checklist PRE-OPERATION InspectionSafe Operating Precautions OperationFuel Recommendations RefuelingRemove the fuel tank cap a Before Starting the Engine Starting the EnginePosition the engine switch to on Stopping the Engine AC Operation AC Capacity Wattage Reference Table Power Management DC OperationOperation Disconnecting the Battery Charging Cable Smart Throttle SystemStandby Power Connections to a Building Electrical SystemParallel operation procedure Parallel Generator OperationShutting off the generators High Altitude Use Carburetor ModificationSource of Emissions Emission Control System InformationAlterations Problems Affecting Emissions Replacement PartsMaintenance Importance of MaintenanceMaintenance Safety Safety PrecautionsPeriodic Maintenance Periodic Maintenance ChartOpening the Service Door Initial Maintenance Fuel SystemHour Initial Break-In Fuel Line InspectionOFF Oil Recommendation Engine OilOil Level Inspection Oil Change Procedure Maintenance Air Filters Air Filter InspectionAir Filter Cleaning Air Filter ReplacementSpark Plug Inspection and Replacement Spark PlugGap should be 0.6 0.7 mm Transportation Transportation and StorageTransporting the Generator Storage Storage PreparationAccessing the Fuel Tank Draining Fuel from the Fuel Tank and Carburetor Fogging the Engine Storage Precautions Removing from StorageSpecifications General SpecificationsPolaris Lubricants and Maintenance Products Modified coefficient table of ambient condition powerWiring Diagrams P1000i Wiring DiagramP2000i Wiring Diagram Red Gray Brown White BlackTroubleshooting Troubleshooting SymptomsEngine Will Not Turn Over Engine Turns Over, but Will Not StartEngine Lacks Power Engine BackfiresEngine Pings or Knocks Engine Runs Irregularly, Stalls, or MisfiresNo Power at DC Receptacle Possible Lean Solution Fuel CauseNo Power at AC Receptacles Engine Stops or Loses PowerWarranty About this Warranty Document Warranty Registration FormWarranty Period Warranty Exclusions Polaris Power Generator Owner Responsibility Important Notice Maintenance LOG DATE/HOURS Service Comments Supplier Permormed TechnicianIndex Label LocationIndex PMS