Polaris P2000i, P1000i manual Engine Oil, Oil Recommendation, Oil Level Inspection

Page 50

MAINTENANCE

Engine Oil

Oil Recommendation

Oil directly affects performance and service life. Use a 4-stroke automotive detergent oil. POLARIS 5W-30 Engine Oil is recommended for this generator.

The SAE oil viscosity and service category are in the API label on the oil container. POLARIS recommends the use of API service category “SJ” or later, equivalent oil.

Oil Level Inspection

Failure to use the proper 4-stroke engine oil may result in engine damage.

Using non-recommended oil may cause serious engine damage. Never substitute or mix oil brands.

Note: Inspect the oil level before each use with the engine stopped and the generator on a level surface.

1. Open the service door.

	2. Remove the oil filler cap /	A
	dipstick (A) and wipe it clean.	A
	dipstick (A) and wipe it clean.

3. Insert the dipstick (A) into filler neck, without screwing it in, to inspect the oil level.

4. Remove the dipstick and				B
verify that the oil is at the
upper limit (B). Add
additional oil and inspect the
additional oil and inspect the
level as needed until the upper


limit has been reached.
limit has been reached.

5.Re-install the dipstick (A).

6.Re-install the service door.

49

Image 50

Contents Polaris Power Table of Contents Introduction WelcomeIntended Use Safety Precautions Signal Words and Safety Terms Alcohol or Drug USEIdentification Numbers and Locations P1000iP2000iGeneral SafetySafety Warnings and Precautions Before and During OperationFire Safety Operator Safety Fuel Safety Carbon Monoxide Safety Electrical Safety Extension Cord Information Equipment ModificationsOutdoor Use only Danger Label Safety Labels and LocationsCarbon Monoxide Warning Hot Exhaust CautionSafety Controls and Features Generator ComponentsControl Panel Components P1000i P2000iFuel Tank Cap Vent Lever Engine Fuel SwitchChoke Lever Starter Recoil GripSmart Throttle Switch DC Receptacle and FuseAC Receptacles Indicator PanelGround Terminal Overload Protector Reset Switch Parallel ReceptaclesFirst USE Instructions Adding Engine OilFuel Recommendation Adding Fuel Pre-Operation Checklist PRE-OPERATION InspectionFuel Recommendations Safe Operating PrecautionsOperation RefuelingRemove the fuel tank cap a Before Starting the Engine Starting the EnginePosition the engine switch to on Stopping the Engine AC Operation AC Capacity Wattage Reference Table Power Management DC OperationOperation Disconnecting the Battery Charging Cable Smart Throttle SystemStandby Power Connections to a Building Electrical SystemParallel operation procedure Parallel Generator OperationShutting off the generators High Altitude Use Carburetor ModificationAlterations Emission Control System InformationSource of Emissions Problems Affecting Emissions Replacement PartsMaintenance Importance of MaintenanceMaintenance Safety Safety PrecautionsPeriodic Maintenance Periodic Maintenance ChartOpening the Service Door Hour Initial Break-In Initial MaintenanceFuel System Fuel Line InspectionOFF Oil Level Inspection Engine OilOil Recommendation Oil Change Procedure Maintenance Air Filters Air Filter InspectionAir Filter Cleaning Air Filter ReplacementSpark Plug Inspection and Replacement Spark PlugGap should be 0.6 0.7 mm Transporting the Generator Transportation and StorageTransportation Storage Storage PreparationAccessing the Fuel Tank Draining Fuel from the Fuel Tank and Carburetor Fogging the Engine Storage Precautions Removing from StorageSpecifications General SpecificationsPolaris Lubricants and Maintenance Products Modified coefficient table of ambient condition powerWiring Diagrams P1000i Wiring DiagramP2000i Wiring Diagram Red Gray Brown White BlackEngine Will Not Turn Over TroubleshootingTroubleshooting Symptoms Engine Turns Over, but Will Not StartEngine Lacks Power Engine BackfiresEngine Pings or Knocks Engine Runs Irregularly, Stalls, or MisfiresNo Power at DC Receptacle Possible Lean Solution Fuel CauseNo Power at AC Receptacles Engine Stops or Loses PowerWarranty About this Warranty Document Warranty Registration FormWarranty Period Warranty Exclusions Polaris Power Generator Owner Responsibility Important Notice Maintenance LOG DATE/HOURS Service Comments Supplier Permormed TechnicianIndex Label LocationIndex PMS