Polaris manual Control Panel Components, P1000i P2000i

Page 18

CONTROLS AND FEATURES

Control Panel Components:

		T	K	T	U	K
	N		Q			Q
	N		R			Q
	M		R	N		R
			S	M		S
			S			S
	U		O			O
			O			O
		P			P
					P
		P1000i			P2000i

	ITEM	NOMENCLATURE		DESCRIPTION

	K	SMART Throttle Switch		Automatically reduces engine speed when
	K	SMART Throttle Switch		loads are shut off or disconnected
				loads are shut off or disconnected

	M	DC Fuse Protector		Protects DC charging circuit from overloads

	N	12V DC Receptacle		Charges 12V DC batteries

	O	Ground Terminal		Provides ground for non-conductive metal
	O	Ground Terminal		parts and receptacle ground terminals
				parts and receptacle ground terminals

	P	240V AC Receptacles		Provides two connections for properly rated
	P	240V AC Receptacles		AC appliances
				AC appliances

	Q	Output Indicator		Illuminates GREEN when the generator is
	Q	Output Indicator		operating normally
				operating normally

	R	Overload Indicator		Illuminates RED for appliance short circuits
	R	Overload Indicator		or overloads
				or overloads

	S	Low Oil Indicator		Illuminates RED prior to the oil level falling
	S	Low Oil Indicator		below a safe limit
				below a safe limit

	T	Overload Reset Switch		Resets the circuit after an AC overload

	U	Parallel Receptacles		For use with proper POLARIS Parallel kits

17

Image 18

Contents Polaris Power Table of Contents Introduction WelcomeIntended Use Safety Precautions Signal Words and Safety Terms Alcohol or Drug USEIdentification Numbers and Locations P1000iP2000iGeneral SafetySafety Warnings and Precautions Before and During OperationFire Safety Operator Safety Fuel Safety Carbon Monoxide Safety Electrical Safety Extension Cord Information Equipment ModificationsOutdoor Use only Danger Label Safety Labels and LocationsCarbon Monoxide Warning Hot Exhaust CautionSafety Controls and Features Generator ComponentsControl Panel Components P1000i P2000iFuel Tank Cap Vent Lever Engine Fuel SwitchChoke Lever Starter Recoil GripSmart Throttle Switch DC Receptacle and FuseIndicator Panel Ground TerminalAC Receptacles Overload Protector Reset Switch Parallel ReceptaclesFirst USE Instructions Adding Engine OilFuel Recommendation Adding Fuel Pre-Operation Checklist PRE-OPERATION InspectionFuel Recommendations Safe Operating PrecautionsOperation RefuelingRemove the fuel tank cap a Before Starting the Engine Starting the EnginePosition the engine switch to on Stopping the Engine AC Operation AC Capacity Wattage Reference Table Power Management DC OperationOperation Disconnecting the Battery Charging Cable Smart Throttle SystemStandby Power Connections to a Building Electrical SystemParallel operation procedure Parallel Generator OperationShutting off the generators High Altitude Use Carburetor ModificationEmission Control System Information Source of EmissionsAlterations Problems Affecting Emissions Replacement PartsMaintenance Importance of MaintenanceMaintenance Safety Safety PrecautionsPeriodic Maintenance Periodic Maintenance ChartOpening the Service Door Hour Initial Break-In Initial MaintenanceFuel System Fuel Line InspectionOFF Engine Oil Oil RecommendationOil Level Inspection Oil Change Procedure Maintenance Air Filters Air Filter InspectionAir Filter Cleaning Air Filter ReplacementSpark Plug Inspection and Replacement Spark PlugGap should be 0.6 0.7 mm Transportation and Storage TransportationTransporting the Generator Storage Storage PreparationAccessing the Fuel Tank Draining Fuel from the Fuel Tank and Carburetor Fogging the Engine Storage Precautions Removing from StorageSpecifications General SpecificationsPolaris Lubricants and Maintenance Products Modified coefficient table of ambient condition powerWiring Diagrams P1000i Wiring DiagramP2000i Wiring Diagram Red Gray Brown White BlackEngine Will Not Turn Over TroubleshootingTroubleshooting Symptoms Engine Turns Over, but Will Not StartEngine Lacks Power Engine BackfiresEngine Pings or Knocks Engine Runs Irregularly, Stalls, or MisfiresNo Power at DC Receptacle Possible Lean Solution Fuel CauseNo Power at AC Receptacles Engine Stops or Loses PowerWarranty About this Warranty Document Warranty Registration FormWarranty Period Warranty Exclusions Polaris Power Generator Owner Responsibility Important Notice Maintenance LOG DATE/HOURS Service Comments Supplier Permormed TechnicianIndex Label LocationIndex PMS