RedMax EBZ8050RH manual Fuel, Gasoline Requirements, OIL Requirements, Warranty

Page 11

EBZ8050/RH

7. Fuel

FUEL

lines or fuel tank of the engine.

WARNING

• Gasoline is very flammable. Avoid smoking or bringing any

NOTE

• Failures caused by operating engines on gasoline with octane

flame or sparks near fuel. Make sure to stop the engine and

rating lower than 89 are not covered by the RedMax Two-

U

allow it cool before refueling the unit. Select outdoor bare

ground for fueling and move at least 10 ft (3 m) away from

the fueling point before starting the engine.

Stroke engine warranty.

WARNING

S

■GASOLINE REQUIREMENTS

• All 2-Stroke RedMax Products are powered by Zenoah Professional-Commercial Duty, Hi-Performance, Hi-RPM, Air Cooled 2-Stroke engines.

RedMax/Zenoah – Hi-Performance 2-stroke engines produce higher HP outputs as compared to standard Home Owner Duty or Light Commercial Duty production engines offered by most manufacturers.

• Exhaust emission are controlled by the fundamental engine parameters and components (eq., carburation, ignition timing and port timing) without addition of any major hardware or the introduction of an inert material during combustion.

• The RedMax/Zenoah Engines are registered and certified with CARB (California Air Resources Board) and EPA (Environmental Protection Agency) to operate on CLEAN Mid- grade 89 octane or Premium, unleaded (lead-free) gasoline and RedMax Air-Cooled "Max Life", Synthetic blend Premium two- stroke engine oil mixed at 50:1 ratio.

• Unleaded gasoline is recommended to reduce the contamination of the air for the sake of your health and the environment.

• This Hi-Performance Air Cooled 2-stroke Engine requires the

use of Minimum 89 Octane [ R+M ] (Mid grade or Premium) 2

clean gasoline. Gasoline may contain maximum of 10% Ethanol (grain alcohol) or up to 15% MTBE (Methyl tertiary-butyl ether). Gasoline containing Methanol (Wood Alcohol) is NOT approved.

NOTE

•IF octane rating of the Mid Grade gasoline in your area is lower than 89 Octane use Premium Unleaded Gasoline. The majority of all 2-stroke engine manufacturers in the USA and Canada recommend using gasoline with 89 Octane or higher.

WARNING

•Gasoline with an octane rating lower than 89 will greatly increase the engines operating temperature. Low octane gasoline will cause detonation (knock) resulting in piston seizures and major internal engine components damage.

•Poor quality gasolines or oils may damage sealing rings, fuel

•Alternative Fuels (Not Gasoline)

Alternative fuels, such as E-15 (15% ethanol), E-20 (20% ethanol), E-85 (85% ethanol) are NOT classified as gasoline and are NOT approved for use in RedMax 2-stroke gasoline engines. Use of alternative fuels will cause major engine performance and durability problems such as: improper clutch engagements, overheating, vapor lock, power loss, lubrication deficiency, deterioration of fuel lines, gaskets and internal carburetor components, etc... Alternative fuels cause high moisture absorption into the fuel/oil mixture leading to oil and fuel separation.

■OIL REQUIREMENTS

•Use only RedMax "Max Life", Synthetic blend Premium Air- Cooled two-stroke engine oil or oil certified to ISO-L-EGD (ISO/CD1378) standard AND one that is JASO-FD registered. RedMax Air-Cooled "Max Life", Synthetic blend Premium two stroke engine oil and ISO-L-EGD (ISO/CD1378) AND JASO-FD oils are fully compatible with gasoline's containing 10% Ethanol. RedMax Air-Cooled "Max Life", Synthetic blend Premium two stroke engine oil and ISO-L-EGD (ISO/CD1378) AND JASO-FD oils are Universal and should be mixed at 50:1 ratio for all 2 stroke air cooled engines sold in the past regardless of mixing ratios specified in those manuals.

•If the oil is registered with JASO, the JASO Logo with FD and registration number will be displayed on the container. The highest JASO rating is "FD", which equals the ISO-L-EGD rating. Lower ratings are "FC", "FB", and "FA".

•Engine problems due to inadequate lubrication caused by failure to use ISO-L-EGD certified and JASO FD registered oil such as "MaxLife", RedMax Synthetic blend Premium 2-stroke oil WILL VOID THE REDMAX TWO-STROKE ENGINE

WARRANTY.

WARNING

•Do not use NMMA (National Marine Manufacturers Association), BIA (Boating Industry Association), and TCW (two cycle water cooled) oils designed for MoPeds or Outboard, water cooled Marine Engines. Do not use API (American Petroleum Institute), TC (Two Cycle) labeled oils. The API-TC

US-9

Page 10 Page 12
Image 11
Page 10 Page 12
Contents EBZ8050RH Page EBZ8050RH Contents Parts location SpecificationsModel EBZ8050/EBZ8050RH Dimensions L x W x H mm Emission Control Symbols on the machineBefore use For safe operation Storage Fuel safety Avoid noise problem TransportDisposal MaintenanceThrottle Lever EBZ8050RH Set upWaist Belt Optional Accessory Blower TubesGasoline Requirements WarrantyFuel FuelFueling the Unit HOW to MIX Fuel Recommended Mixing Ratio Gasoline 50 OILFor Your Engine LIFE, Avoid Close OperationStarting Engine Emergency Removal Adjusting the Shoulder StrapsAdjusting Idle Speed F14 Stopping Engine EBZ8050Fuel Filter MaintenanceAIR Cleaner Cleaning AIR FilterMuffler Replacement Plug is a NGK CMR7HProcedures to be Performed After Every 100 Hours of USE Spark PlugSholder Strap F25Before Storing the Blower Troubleshooting guideStorage DisposalMode D’EMPLOI Tables des matieres Avertissements DE CE Mode D’EMPLOIFiche technique Emplacement des piecesModel EBZ8050/EBZ8050RH Dimensions LxLxH mm Mesures DE Lutte Contre LES Emissions Symboles utilises sur la machineEtiquettes d’avertissement sur la machine Consignes de securite Sécurité carburant Avant DE Faire Demarrer LE MoteurUtilisation DU Produit TransportEntretien RangementComment eviter les nuisances sonores Protection du corps contre les vibrationsLevier D’ACCELERATION EBZ8050RH Ceinture Accessoire OptionnelleAssemblage Tuyaux DE SoufflerieTypes DE Carburants Requis CarburantCarburant Eviter Pour Prolonger LA Duree DE VIE DU Moteur ’ANNULATION DE LA Garantie DU Moteur a Deux Temps RedMaxFaire attention à ne pas trop remuer le carburant Remplissage DU ReservoirEBZ8050/RH FR-11 Ouvrir Fermer Bras DE Commande EBZ8050 F5Fonctionnement Demarrage DU MoteurReglage DE LA Vitesse AU Ralenti F14 Arret DU Moteur EBZ8050Pour Retirer EN CAS D’URGENCE Filtre a Carburant EntretienFiltre À AIR Nettoyage DU Filtre a AIREchappement LA Bougie DE Remplacement EST UNE NGK CMR7HBougie Grille D’ARRET D’ETINCELLESCourroie DE Décharge F24 F25Inspection DE L’ÉCARTEMENT DE LA Bougie D’ALLUMAGE Ecartement 40 mm 0,35 0,45 mm Rotor Bobine d’allumageAvant DE Stocker LA Soufflerie RangementMise au rebut Guide de localisation des pannesPage Soplador DE Mochila Notas Sobre LOS Tipos DE Advertencia ContenidoEspecificaciohes Situación de las piezasControl DE Emisiones Etiqueta de advertencia en la máquinaSímbolos presentes en la máquina Que es una sustan-cia sumamente peligrosa Instrucciones de seguridadSeguridad en el uso del combusible Antes DE Arrancar LA MáquinaUSO DEL Producto TransporteMantenimiento Cómo evitar problemas de ruidoAlmacenamiento Para la protección contra las vibracionesEliminación Los productos RedMaxCorrea Para LA Cintura Accesorio Opcional MontajeTubos DEL Soplador Palanca DEL Regulador EBZ8050RHRequerimientos de la Gasolina CombustibleCombustible Para Contribuir a LA Vida Útil DEL MOTOR, Evite Anulará Lagarantía DEL Motor DE DOS Tiempos RedMaxPreste atención en la agitación Abastecimiento DE LA UnidadVacíe del carburador el combustible compuesto Abrir Cerrar UsoBrazo DE Control EBZ8050 F5 Arranque DEL MotorAjuste DE LA Velocidad DE Marcha Mínima F14 Cómo Ajustar LOS Tirantes DE HombroCómo Apagar EL Motor EBZ8050 Para Soltar EL Equipo EN Caso DE EmergenciaFiltro DE Combustible MantenimientoDepurador DE Aire Limpieza DEL Depurador DE AireApagachispas BujíaBujía DE Recambio NGK CMR7H SilenciadorPresilla Inspección DEL Entrehierro DE LA Bobina DE EncendidoBandolera Antes DE Almacenar EL Soplador 12. Guía de localización y solución de problemasAlmacenamiento EliminaciónNota Parts listRemarque Blower Group EBZ8050/EBZ8050RH S/N 90100101 and up Qty Key# Part Number Description 848-L58-55A4Volute Case Qty Key# Part Number DescriptionEngine Group EBZ8050/EBZ8050RH S/N 90100101 and up Part Number Description Qty Key# Part Number Description Qty Carburetor Assy WYA-44Lever SET EBZ8050 S/N 90100101 and up Page Page Zenoah AMERICA, INC
Top Page Image Contents