Campbell Hausfeld PW2515 Maintenance Schedule, Technical and Consumer Information

Pressure Washer

Maintenance

Observe regular maintenance intervals to ensure maximum performance and life from the pressure washer. Refer to the schedule for recommended maintenance. If you operate the pressure washer in dusty conditions, perform maintenance checks more often.

ENGINE OIL CHANGING INSTRUCTIONS

!CAUTION

Before tipping the engine or equipment to drain oil, drain fuel from the fuel tank.

NOTE: Change oil while the engine is cool.

1.Disconnect the spark plug wire from the spark plug.

2.Locate and remove the engine oil drain plug (See Figure 13).

3.Drain old oil.

4.Replace the drain plug and set the unit upright.

5.Refill the unit with new oil of a recommended type and quantity. Fill the unit to the proper level shown on the dipstick.

PUMP OIL CHANGING INSTRUCTIONS

Changing or refilling the oil in the pump requires removal of Figure 13 - Oil Drain Location the pump from the engine and should not be required unless

oil has leaked out due to worn or damaged oil seals in the pump. If oil has leaked out of the pump, bring the pressure washer to a certified Campbell Hausfeld service center for repair.

Maintenance Schedule

Maintenance Schedule		Action needed
Daily	• Check water inlet screen and
		filter.
	• Check engine oil levels. Fill as
		necessary.
	• Check gasoline level. Fill as
		necessary.
After first 5 hours of	• Change engine break-in oil.
operation		Use SAE30 or 10W-30
		detergent oil.
Every 25 hours of	• Change oil if operating under
operation		heavy load or high ambient
		temperature.
	• Clean or replace paper air
		cleaner cartridge. Tap gently
		to remove dirt.
Every 50 hours of	• Change oil.
operation	• Replace spark plug.
Each 100 hours of	• Replace paper air cleaner
operation or every 3		cartridge.
months	• Change engine oil.

Technical and Consumer Information

Vertical Oriented Pressure Washers

Engine Oil Type	SAE 10W-30
	SAE 30W (Above 60˚ F)
Engine Oil Capacity
Honda engines	18.5 fl. oz.
Engine Fuel Capacity
Honda engines	0.29 gal
Pump Oil Type
Wobble pumps	SAE20W or SAE30W
	non-detergent oil
Pump Oil Capacity
Vertical wobble pumps	4.0 fl. oz.
Pump Detergent Suction
Water to detergent ratio	8 to 1 (12% detergent)
Water Supply Requirements
Minimum inlet pressure	20 psi
Maximum inlet pressure	100 psi
Maximum inlet temperature	100˚ F
Minimum inlet flow rate	5 gpm
Inlet garden hose size	5/8” I.D.
Maximum inlet garden
hose length	50 ft

www.chpower.com

10