Cybex International 710T C6 Csafe Port Check, C7 Tone Generator Check, C8 Speed Sensor Count

Page 79

Cybex 710T Treadmill Owner’s Manual

NOTE: Press the START/ENTER key last, because although it emits a tone, it will also cause you to exit the C5 test and return to the diagnostic menu. If you press STOP, it will exit from the Diagnostic Test Mode.

If you locate a key that is not functioning properly, a trained Cybex service technician can disassemble the control panel and replace the overlay switch membrane.

C6: CSAFE PORT CHECK

This test checks the status of the CSAFE port on the back of the console. CSAFE is the industry standard for connecting to fitness equipment. The port is tested at the factory, but the status can be checked at any time. The test will indicate one of four states:

CSAFE OK

Communication has been established

OPEN

No comm. or open port

LOOP OK

Factory test using a test plug

NO POWER Factory test using a test plug

C7: TONE GENERATOR CHECK

This test checks the tone generator on the control panel. With C7, you can determine whether the tone generator needs to be replaced.

When you press START/ENTER to begin this test, the control panel displays the message “START.”

The test sends seven electrical signals to the tone generator and you should hear seven audible tones in return. A defective tone generator will not produce any tones.

Press START/ENTER to end this test and return to the diagnostic test menu.

C8: SPEED SENSOR COUNT

This test displays the actual speed sensor’s count of gear teeth. The speed sensor gear is mounted on the drive motor shaft.

At 1 mph the count is approximately 99.

At 2 mph the count is approximately 199.

At 3 mph the count is approximately 298.

At 4 mph the count is approximately 398.

At 5 mph the count is approximately 497.

At 6 mph the count is approximately 597.

At 7 mph the count is approximately 696.

At 8 mph the count is approximately 795.

At 9 mph the count is approximately 895.

At 10 mph the count is approximately 995.

Page 7-16

Page 78 Page 80
Image 79
Page 78 Page 80
Contents Cybex 710T Treadmill FCC Compliance Information About This ManualDeclaration of Conformity Table of Contents Page Grounding Instructions Important Voltage InformationImportant Safety Instructions Important Safety Instructions Emergency Stop Risk of Personal Press the Stop key once to bring the running belt to a stop Emergency StopPage Specifications Technical SpecificationsPage Detailed Operation Guide Quick Operation GuideSTART/ENTER Activating the Treadmill Follow the steps below Stopping the Treadmill Control During Operation Meaning of terms Data ReadoutsDisplaying Heart Rate Selecting Programs & OptionsUse of Programs P1 Fitness Test Program Manual ModeOperation P2 Weight Loss Program P2 Program Profile P3 Cardiovascular Program Operation P4 Speed Challenge Program Operation P5 Express Program P6 Hill Interval Program P7 Speed Interval Program P8 Pikes Peak Program P9 River Run Program P10 Program Profile P10 5 Kilometer ProgramP101-P110 Saved Program P11 Demonstration ProgramMonitoring Your Heart Rate Workout TipsTake your heart rate Approx Maximum 85% Heart Rate Age Determine your target heart rateCleaning Your Treadmill Regular Maintenance ActivitiesRunning Belt Maintenance Re-center the belt Re-tension the beltRemove the motor cover and side rails Turn the power offCheck the belt and deck condition Replace the side rails and motor cover Clean under the beltOther Preventive Maintenance Service Schedule Log Sheet Choosing & Preparing a Site Quick SetupItem Qty Description Unpacking Electrical Power RequirementsHardware Bags Attach the upright cross brace Assembling the TreadmillMove the base into position Attach the right uprightStar Attach the console to the left uprightAttach the console and left upright to the treadmill Attach the front panel Connect the cablesPosition the pads Attach the motor coverConnect Csafe Test the 710T Operation Programs On/Off Mode C14 Setting Operation OptionsMetric/English Measurement Units Pause Time C17 Service Reminders C19Time Limit C15 Speed Limit C16Page Serial Number & Voltage Contacting ServiceWarranty Limited Warranty to NON-CONSUMER BuyersExpiration of Limited Warranties for NON-CONSUMER Buyers Limited Warranty to Consumer BuyersDisclaimer of Warranties and Limitation of Remedies Expiration of Limited Warranties for Consumer BuyersProcedure for Obtaining Warranty Performance Return Material Authorization RMAOrdering Parts Damaged PartsPage Motor Brushes Service InstructionDisconnect the motor cable Turn the power onElevate the treadmill Remove the motor coverSecure the brush caps Secure the brushesSecure the motor cover Clear the error logMotor Current & Voltage Secure the front panelMeasure current draw Measure Motor Voltage at Max Speed, No Load230V Remove the front panelMeasure motor voltage 115VSecure the side rails and motor cover Running Belt & DeckRemove the side rails Loosen the deck Remove the rear rollerLoosen the drive belt Front Roller Drive BeltAttach the running deck Attach the drive belt tensioning assemblyReinstall the side rails and end caps Rear RollerError 1 No Speed Signal at Startup Error CodesError 3 Loss of Speed Signal Error 2 Excessive Current DrawError 50 Overspeed Error 70 Loss of Novram Information Diagnostic TestsC1 Program Revision Level C18 Power Relay Tests C19 Service RemindersC5 Overlay Test C2 Actual SpeedC3 Current Draw C4 LED TestC7 Tone Generator Check C6 Csafe Port CheckC8 Speed Sensor Count C11 Total Hours C12 Error LOGC9 Incline Sensor C10 Total MileageC15 Time Limit C18 Power Relay TestC19 Service Reminders C14 PGM LockoutService QTY Description Parts ListQTY Description NS = Not Shown Page Based on SC-710T Rev E

LT-14464-4 Rev H, 710T specifications

The Cybex International 710T, LT-14464-4 Rev H is a top-tier piece of fitness equipment designed for commercial gym settings and serious home workout enthusiasts. This high-performance treadmill stands out due to its innovative features, robust design, and technology that prioritizes user comfort and efficiency.

One of the central features of the 710T is its advanced mechanics, which include a powerful DC motor that provides a smooth and consistent performance across various speeds. With a top speed of 12 miles per hour and an incline of up to 15%, users can engage in a diverse range of workouts that simulate outdoor running and walking environments. This versatility makes the 710T suitable for users of different fitness levels, from beginners to seasoned athletes.

The treadmill also boasts a spacious running surface of 22 inches by 60 inches, allowing for comfortable strides and reduced risk of injury. The patented FlexTech® system is engineered to absorb impact, providing a cushioned deck that minimizes stress on joints while still allowing for an effective workout. This technology promotes longer exercise sessions, which can contribute to better overall fitness goals.

Another remarkable feature is the intuitive console equipped with a large, easy-to-read display that offers users essential metrics, including time, distance, calories burned, and heart rate. The console is designed for simplicity and ease of use, with quick-access buttons for speed and incline adjustments, enabling users to customize their workouts effortlessly.

Connectivity is a significant aspect of modern workout experiences, and the 710T does not disappoint. It includes built-in Bluetooth compatibility, allowing users to sync their devices with fitness apps for tracking and sharing workout progress. Additionally, the integrated USB charging port ensures devices remain powered during exercise, allowing for uninterrupted music or entertainment.

Safety is a top priority, and the Cybex 710T is equipped with emergency stop features and adjustable handrails for added stability. The durable construction of the treadmill makes it suitable for heavy daily use, ensuring longevity and reliability.

In summary, the Cybex International 710T, LT-14464-4 Rev H is a comprehensive treadmill engineered with innovative technology, robust design, and user-friendly features that cater to various fitness needs. Its combination of performance, safety, and connectivity epitomizes the philosophy of Cybex in promoting an efficient and enjoyable workout experience.
Top Page Image Contents