55
WFL 2060 Service Tips | (4) | |||||||
|
| ram (4) | ||||||
| Fault |
| Possible Causes |
| Flashing | Program Fault |
| |
|
|
| Lights | Occurred |
| |||
|
|
|
|
|
| |||
| Door open or | | Door left open. |
| Door locked | Wash |
|
|
| won’t lock | | Faulty door latch or door lock. |
| Rinse/Spin |
|
| |
|
| Wash |
|
|
| |||
|
|
|
|
|
|
|
|
|
| No water | | Water shut off. |
| Door locked |
|
|
|
| filling | | Inlet strainer filters blocked. |
| Rinse/Spin | Wash |
|
|
|
| Wash |
|
| ||||
|
| Water pressure too low (< 1 bar) |
|
|
|
|
| |
| No heating | | Faulty heater. |
| Door locked |
|
|
|
|
| | Voltage too low. |
| Rinse/Spin |
| Test |
|
|
|
| Wash |
|
| |||
|
| Excessive scale on heating element. |
|
|
|
|
| |
| No draining | | Blocked sensor. |
| Door locked |
|
|
|
|
| | Faulty water level controller. |
| Rinse/Spin | Wash |
|
|
|
|
| Wash |
|
| |||
|
| Faulty or blocked drain pump. |
|
|
|
|
| |
| Motor won’t | | Faulty speed control. |
| Door locked |
|
|
|
| run | | Triac |
| Rinse/Spin |
| Test |
|
|
| Wash |
|
| ||||
|
| | Faulty reversing relay. |
|
|
|
|
|
| Overheating | | Faulty control module. |
| Door locked |
| Test |
|
|
|
|
| Rinse/Spin |
|
| ||
|
|
|
|
| Wash |
|
|
|
|
|
|
|
|
|
|
|
|
| NTC failed | | Faulty wire harness. |
| Door locked |
|
|
|
| (short or open | | Faulty NTC. |
| Rinse/Spin |
| Test |
|
|
| Wash |
|
| ||||
| circuited) |
|
|
|
|
|
|
|
HINT: Using the test program can cut down repair times & eliminate repeat calls from misdiagnosing problems.
1st Edition/Revision 5 (1/20/04)