Multiquip HHXG5 operation manual DIMENSIONS/SPECIFICATIONS Trowel, HHX Specifications

Page 14

DIMENSIONS/SPECIFICATIONS (TROWEL)

Figure 1. HHX Dimensions

 

Table 1. HHX Specifications

 

 

 

SPECIFICATION PARAMETER

 

HHXG5 (VANGUARD)

A–Length – in. (cm)

 

98.00 (249)

 

 

 

B–Width – in. (cm)

 

50.0 (127)

 

 

 

C–Height – in. (cm)

 

54.0 (137.2)

 

 

 

Weight – lbs. (kgs.) Operating

 

1,397 (634)

 

 

 

Weight – lbs. (kgs.) Shipping

 

1,472 (668)

 

 

 

Sound Pressure – dBA2

 

tbd

Vibration – ft/s2 (m/ s2)3

 

tbd

Blade Tip Speed – FPM (m/s)

 

1425 (7.24)

 

 

 

Fuel Tank – gallons (liters)

 

9 (34)

 

 

 

Rotor – RPM

 

40 to 170

 

 

 

Path Width – in. (cm)

 

91 (231)

 

 

 

Hydraulic Oil4

 

Whiteman P/N 10139 0r ISO 680

 

 

 

NOTICE

1.Sound pressure is "A" weighted . Measured at the operators ear position while the ride-on trowel is operating at full throttle on concrete in a manner most often experienced in “normal ” circumstances. Sound pressure may vary depending upon the condition of the concrete. Hearing protection is always recommended.

2.The vibration level indicated is the maximum RMS (Root Mean Square) value obtained at the handle grip while operating the ride-on trowel on curing concrete in a manner most often experienced in “normal ” circumstances. Values were obtained from all three axes of motion. The values shown represent the maximum RMS value from these measurements.

page 14 — HHXg5 RIDE-ON TROWEL • operation manual — rev. #1 (10/25/10)

Image 14
Contents Model HHXG5 Proposition 65 Warning Respiratory Hazards Silicosis/Respiratory WarningsSilicosis Warning Table of Contents HHXG5 Ride-On TrowelPage Training checklist CompletelyDaily pre-operation checklist Daily pre-Operation ChecklistSafety Information SaFeTY meSSageSGeNeRaL SaFeTY Order Form PT-160 TROWeL SaFeTYENgINe SaFeTY Before servicing equipment„ Use well-insulated gloves when picking up the battery FueL SaFeTYBaTTeRY SaFeTY Lifting TRaNSpORTINg SaFeTYTOWINg SaFeTY „ aLWaYS shutdown engine before transportingENvIRONmeNTaL SaFeTY DIMENSIONS/SPECIFICATIONS Trowel HHX SpecificationsSpecifications Engine FuelGeneral Information Controls and Indicators HHXG5 Controls and Indicators FrontHHXG5 Controls and Indicators Rear HHXG5 Controls and Indicators Clamshell Open Engine Components Gasoline Linked to the accelerator systemBattery Setup SetupTrowel Setup Instructions Gearbox Oil Level InspectionEngine Oil Level FuelOperation Starting the EngineSteering Control Joystick Directional PositioningBlade Pitch Matching Blade Pitch for Both Sets of BladesWeekly 30-40 Hours MAINTENANCEMaintenance Schedule Daily 8-10 Hours Monthly 100-150 HoursOil Filter 300 Hours Air Cleaner DailyChanging Engine Oil And Filter Fuel FilterOil And Fuel Lines Battery/Charging SystemOil/Water Separator Radiator/Cooling SystemRemoving the Drive Belt MAINTENANCE old style clutchChecking The Drive Belt Installing the Drive Belt Using New Drive Belt Expanding Lower Drive PulleySpare Drive Belt Replacement Left Side GearboxHow It Works Figure Springs High Engine RPM Driven PulleyClutch Spring Driven Pulley CAM Bracket Moveable Fixed FaceMAINTENANCE new style clutch Belt measurementInstalling Drive Belt Lower drive pulleyHow it works Single Pitch MAINTENANCE TrowelBlade Pitch Adjustment Procedure Twin PitchTMChanging Blades Steering AdjustmentClean-Up „„Do the pitch control towers rock back and forth?Place the trowel in a FLAT, Level area Trowel Arm AdjustmentAssembly Distance from the lower wear plateRemove the trowel arm from the spider plate Trowel Blade RemovalTrowel Arm Removal Locate the trowel arm adjustment tool P/N Checking Trowel Arm StraightnessLifting/Crush Hazard.DO not lift trowel with pans attached Re-AssemblyInstalling Pans Onto Finisher Blades Verify the hydraulic fluid level is correct Checking Steering PressureHydraulic Steering Pressure Move the throttle lever to Full engine RPMSteering Pressure Adjustment Steering Pressure CheckDecommissioning trowel Decommissioning Trowel/ComponentsWiring Diagram Engine StarterConnector Orientation Front View Relay Orientation Troubleshooting Symptom Possible problem SolutionTroubleshooting Ride-On Trowel Troubleshooting engine Air cleaner dirty? Clean or replace air cleaner HERE’S HOW to GET Help
Related manuals
Manual 68 pages 56.17 Kb