Ducane 3100 owner manual Gas Leak Checks, Leaks. Use of an open flame may result in serious bodily

Page 22

CONNECTION — Liquid Propane Gas Grills

m WARNING: An LP (propane) tank is overfilled if it contains more than 80% by weight of its total capacity of propane (LP). An incorrectly filled or an overfilled LP (propane) tank can be dangerous. If this information is not followed exactly, a fire causing death or serious injury may occur. If a tank is overfilled and the weather causes the warming of the LP tank, (a hot day, tank left in sun or stored indoors) internal pressure is created due to expansion of the propane which in turn causes the LP gas to be released through the pressure relief valve on the tank. The pressure relief valve is a safety device required on 20 lb. propane tanks by the Department of Transportation to prevent a catastrophic tank failure due to excessive pressure. LP gas released from the tank is flammable and can be explosive.

Gas Leak Checks

Remove Control Panel for Leak Testing

1) Remove control knobs.

2)Remove the two (2) screws and washers holding each valve to the control panel

and control knob bezel.

3)Loosen the control panel by removing two (2) screws from each side of the front

control panel.

4) Pull control panel away from grill.

Never use a match or flame for leak detection. Use soapy water or testing solution. Brush the solution onto connection points and look closely for bubbles indicating escaping gas. If leaks are detected, shut off the main gas supply valve and securely retighten connections, then repeat the leak test.

On cabinet models, perform this operation before placing the tank into its storage compartment. After placing the tank in the compartment, recheck the tank to see if any connections were disturbed.

m

warning: Never use an open flame when testing for gas

3100/4100

 

leaks. Use of an open flame may result in serious bodily

 

injury or death, or in a fire or an explosion causing damage

 

 

to property.

 

Check:

 

1)

Gas supply hose-to-manifold connection.

 

m

WARNING: If there is a leak at connection (1), retighten

 

 

the fitting with a wrench and recheck for leaks with soap

 

 

and water solution. If a leak persists after retightening the

 

 

fitting, turn OFF the gas. DO NOT OPERATE THE GRILL.

 

 

Contact the Customer Service Representative in your area by

 

 

calling 1-800-382-2637.

 

2)

Regulator-to-Cylinder connection.

 

3)

The hose-to-regulator connection.

 

4)

Valves-to-manifold connections.

 

m

WARNING: If there is a leak at connections (2), (3) or (4),

 

 

turn OFF the gas. DO NOT OPERATE THE GRILL. Contact

 

 

the Customer Service Representative in your area by calling

 

 

1-800-382-2637.

 

When leak checks are complete, turn gas supply OFF at the source and rinse

 

connections with water.

 

22

 

www.ducane.com

Page 21 Page 23
Image 22
Page 21 Page 23
Contents Customer Service 1-800-DUCANES Wash hands after handling this product Warranty, Garantía, garantie Ducane Products COExploded View Catch Pan Plato recolector Egouttoir Heat Shield Locking CasterExploded View Cooking Grates Control Panel Shroud Assembly Igniter ElectrodeWarming Rack Manifold Assembly Igniter Module Control KnobParts list, Lista DE PIeZAS, Liste DES Piéces 3100Assembly, ENSAMBLAJE, Assemblage Front Frente Avant Nota 3100 4100 Assembly, ENSAMBLAJE, Assemblage 3100 3100 4100 Assembly, ENSAMBLAJE, Assemblage Fully tighten all fasteners at this time 3100 4100 Assembly Safety InformationInstallation Liquid Propane Gas Grills Location of Your GrillConnection Liquid Propane Gas Grills Liquid Propane Tank Safety Tips Leaks. Use of an open flame may result in serious bodily Gas Leak ChecksCheck Normal Operation Main Burner Ignition Match Lighting Your Grill Main BurnersStoring Liquid Propane Gas Grills Helpful HintsFlare Ups Gas Valve OrificeProceeding with any troubleshooting procedures TroubleshootingMaintenance Lead to delayed ignition, resulting in bodily harmCleaning the Burner Box Cleaning the Cooking GrateCleaning the Heat Distribution Plates Grease FiresAnnual Maintenance Inspection of the Spider/Insect ScreensCleaning the Spider/Insect Screens Main Burner Flame PatternCleaning the Main Burner Guía del propietario delasador de gas propano licuado Peligros y advertencias Lávese las manos después de manipular este productoUbicación de la barbacoa Información sobre la seguridadImportante NivelaciónGarantía y, si se realiza de manera incorrecta, pudiera Tipo de gasAcoplamiento conector tipo Resultar en lesiones corporales graves o la muerte, o enControl del exceso de flujo Ensamblaje manualDesconexión del cilindro Almacene el tanque de propano licuado de manera seguraExplosión causando daños a la propiedad Lesiones corporales graves o la muerte, o en un fuego o unaRevise Precalentamiento de la barbacoa Operación NormalAl usar la barbacoa por primera vez Post-calentamiento de la barbacoaEncendido del quemador principal Almacenaje de las barbacoas de gas propano licuado Consejos ÚtilesLlamaradas Orificio de la válvula de gasResolución DE Problemas MantenimientoLimpieza de la caja del quemador Limpieza de la parrilla de cocciónLimpieza de las placas de distribución del calor Mantenimiento Anual Inspección de las mallas contra arañas e insectosLimpieza de las mallas contra arañas e insectos Limpieza del quemador principal Guide de l’utilisateur du Grill à gaz PL Appareils a GAZ Propane Liquide Uniquement InformationS Relatives a LA Securite Choix de l’emplacement de votre grillNivelage du sol Type de bouteille de propane Type de gazInstructions de transport Couplage de raccord de TypeContrôle de débit excessif Montage manuelDéconnexion de la bouteille Fermeture activée par la températurePourrait provoquer des blessures graves, la mort, un VérifiezPréchauffage du grill Utilisation NormaleRodage de votre grill Post-chauffage du grillAllumage du brûleur principal  Avertissement Assurez-vous que 5 minutes se sontEmbrasements AstucesStockage des Grills à gaz propane liquide La bouteille avant d’exécuter toute procédure de dépannage Planning de maintenance du grill à 90 joursGuide DE Depannage Avertissement Le couvercle doit être complètementNettoyage du boîtier du brûleur Nettoyage des plaques de diffusion de la chaleurFeux de friture Maintenance Annuelle Inspection des Grilles anti araignées/insectesNettoyage des Grilles anti araignées/insectes Aspect de la flamme du brûleur principalNettoyage du brûleur principal Thank you for purchasing a Ducane grill Para compras hechas en los Estados Unidos P.O. Box
Related manuals
Manual 60 pages 789 b Manual 60 pages 49.75 Kb

3100 specifications

The Ducane Natural Grill is an exemplary choice for grilling enthusiasts, combining innovative technology with user-friendly features to elevate outdoor cooking experiences. Known for its powerful performance and durable construction, the Ducane 3100 model brings efficiency and convenience to your backyard.

One of the standout features of the Ducane Natural Grill is its sturdy stainless-steel burners, designed to deliver consistent heat across the cooking surface. These burners provide ample cooking power, allowing users to achieve precise cooking results whether searing steaks, grilling vegetables, or roasting whole chickens. The 3100 series boasts a total BTU input capacity that ensures even heat distribution and reduces the risk of hot spots, thereby enhancing cooking reliability.

In terms of design, the Ducane Natural Grill incorporates a spacious cooking area, giving grillers plenty of room to prepare multiple dishes simultaneously. It also features a built-in thermometer, which provides real-time temperature readings, helping users manage cooking times effectively. With its porcelain-coated cast iron grates, the grill not only ensures excellent heat retention but also promotes those coveted grill marks, adding aesthetic appeal to every meal.

The grill's ignition system is another highlight; equipped with a push-button electronic ignition, it guarantees a quick start, getting you grilling in no time. The Ducane 3100 includes side shelves that offer additional prep space, making it easier to organize cooking materials and tools right at your fingertips. Moreover, its wheels ensure mobility, allowing for easy relocation based on your outdoor layout or garden design.

For those who appreciate a well-thought-out construction, the Ducane Natural Grill is built to withstand the elements, featuring a powder-coated finish that helps resist rust and corrosion. This durability, combined with its powerful features, makes it an investment that can endure years of grilling enjoyment.

With its attention to performance, design, and user convenience, the Ducane Natural Grill 3100 stands out in the market. It is ideal for both novice grillers and seasoned chefs alike, providing the versatility and reliability required to create delicious outdoor meals.
Top Page Image Contents