Weber Liquid Propane Grill, 55052 0100 manual Manual Lighting

Page 27

Manual Lighting

DANGER

Failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame- up which can cause serious bodily injury or death.

1)Open the lid.

2)Make sure all burner control knobs are turned OFF. (Push each knob down and turn clockwise to ensure they are in the off position.)

WARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the “excess gas flow control” feature will activate, limiting the flow of gas from the LP cylinder. If this should occur, turn OFF the LP tank valve and burner control knobs. Then start over.

DANGER

When the “excess gas flow control” feature is activated, a small amount of gas is still flowing to the burners. After turning OFF the cylinder and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result in an explosive flame-up, which can cause serious bodily injury or death.

1

2

7

3

4,6 5

*The grill illustrated may have slight differences than the model purchased.

3)Turn the cylinder on by turning the cylinder valve counterclockwise.

4)Strike a match and put the flame into the matchlight hole in the front of the cooking box.

WARNING: Do not lean over open barbecue. Keep your face and body at least one foot away from the matchlight hole when lighting the barbecue.

5)Push Front burner control knob down and turn to START/HI.

6)Check that the burner is lit by looking through the matchlight hole on the front of the cooking box. You should see a flame

WARNING: If the burner does not light, turn the Front burner control knob to OFF and wait 5 minutes to let the gas clear before you try again or try to light with a match.

7)After the FRONT burner is lit you can turn on the other burner.

Note - Always light the FRONT burner first. The other burner or burners ignite from the FRONT burner.

To Extinguish

Push down and turn each burner control knob clockwise to the OFF position. Turn gas supply OFF at the source.

D-2

Image 27
Contents Gas Grill Liquid Propane GAS Units only Customer Service Center South Hicks RoadPalatine, IL Contents For Installation in Canada StorageOperating Genesis Silver-C LP Page Page Page Page Assemble frame Assemble wheel frameAdd front panel Continue frame assemblyComplete frame assembly You will need caster frame and wheel frameInsert casters Add cooking box assemblyInstall cylinder panel Frame brace2Add fuel gauge Install igniter Check that all burner valves are offYou will need burner control knobs Install manifold bracket Install the slide out bottom trayYou will need manifold bracket You will need lid, two hair pin cotters1 and two hinge pins2 Install LidRight swing-up work surface Install the right end trim piece with tool holdersBoard Do not use the swing-up work surface as a cuttingYou will need side burner Install side burnerInstall the left end trim piece and swing-up work Shown, do not push the trim piece in allWay and do not add bolts yet Install the work surface You will need work surfaceDo not use the work surface as a cutting board Closed. Close by turning clockwise Connection. Using a wrench could damageFill liquid propane cylinder Regulator coupling and could cause a gas leakLeaks. Sparks or open flames will result Do not use an open flame to check for gasLeaks. Be sure there are no sparks or open Flames in the area while you check forInstall the thermometer You will need ThermometerYou will need Bottom shelf Lighting To ExtinguishSummary lighting instructions are on the control panel Manual Lighting Lighting only the side burner Lighting the Side BurnerCleaning CookingStorage and/or Nonuse Refilling the Liquid Propane Cylinder Removal of the LP cylinderImportant LP Cylinder Information Liquid Propane Cylinder To Connect the hose to the cylinderSafe handling tips for Liquid Propane Gas Cylinders Liquid Propane LP CylindersLiquid Propane Cylinder requirements Inspection and Cleaning of the Weber Spider Stopper Guards Annual MaintenanceGeneral Maintenance Main Burner Cleaning ProcedureWeber Spider Stopper Guards Replacing Main Burners Crossover Ignition System Operations Orange flame, in conjunction with Barbecue temperature onlyFlame is low when burner is on Burners burn with a yellow orConjunction with the smell of gas Side Burner does not lightFlame is low in High position Flame is very yellow