Weber Liquid Propane Grill manual Burners burn with a yellow or, Orange flame, in conjunction with

Page 37

Troubleshooting

Problem

Check

Cure

Burners burn with a yellow or

Inspect Weber Spider Stopper

Clean Weber Spider Stopper

orange flame, in conjunction with

Guards for possible obstructions.

Guards. (See Section “Annual

the smell of gas.

(Blockage of holes.)

Maintenance”)

 

 

 

 

Burners do not light. -or- Burners

The excess flow satety device,

To reset the excess flow safety

have a small flickering flame in

which is part of the barbecue to

device turn all burner control knobs

the HIGH position. -or-

cylinder connection, may have

and the cylinder valve OFF.

Barbecue temperature only

activated.

Disconnect the regulator from the

reaches 250˚ to 300˚ in the HIGH

 

cylinder. Turn burner control knobs to

position.

 

HIGH. Wait at least 1 minute. Turn

 

 

burner control knobs OFF. Reconnect

 

 

the regulator to the cylinder. Turn

 

 

cylinder valve on slowly. Refer to

 

 

“Lighting Instructions”.

 

 

 

 

Burner does not light, or flame is

Is LP fuel low or empty?

Refill LP cylinder.

low in HIGH position.

 

 

 

Is fuel hose bent or kinked?

Straighten fuel hose.

 

 

 

 

 

 

Does the Front burner light with a

If you can light the Front burner with

 

match?

a match, then check the Crossover

 

 

Ignition System.

 

 

 

 

Experiencing flare-ups:

Are you preheating barbecue in the

All burners on high for 10 to 15

 

prescribed manner?

minutes for preheating.

 

 

 

 

Are the cooking grates and

Clean thoroughly. (See Section

 

Flavorizer bars heavily coated with

“Cleaning”)

 

burned-on grease?

 

 

CAUTION: Do not line the

 

 

 

 

 

 

bottom tray with aluminum foil.

Is the bottom tray “dirty” and not

Clean bottom tray

 

allowing grease to flow into catch

 

 

 

pan?

 

 

 

 

 

Burner flame pattern is erratic.

Are burners clean?

Clean burners. (See Section

Flame is low when burner is on

 

“General Maintenance”.)

HIGH. Flames do not run the

 

 

 

whole length of the burner tube.

 

 

 

 

 

 

Inside of lid appears to be

The lid is porcelain-on-steel, not

Clean thoroughly. (See Section

“peeling.” (Resembles paint

paint. It cannot “peel”. What you are

“Cleaning”.)

peeling.)

seeing is baked on grease that has

 

 

 

turned to carbon and is flaking off.

 

 

 

THIS IS NOT A DEFECT.

 

 

 

 

 

 

If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your region using the contact information sheet provided with your manual.

D-12

Page 36 Page 38
Image 37
Page 36 Page 38
Contents Gas Grill Liquid Propane GAS Units only South Hicks Road Customer Service CenterPalatine, IL Contents Storage For Installation in CanadaOperating Genesis Silver-C LP Page Page Page Page Assemble frame Assemble wheel frameComplete frame assembly Continue frame assemblyYou will need caster frame and wheel frame Add front panelInsert casters Add cooking box assemblyFrame brace2 Install cylinder panelAdd fuel gauge Check that all burner valves are off Install igniterYou will need burner control knobs Install the slide out bottom tray Install manifold bracketYou will need manifold bracket You will need lid, two hair pin cotters1 and two hinge pins2 Install LidRight swing-up work surface Install the right end trim piece with tool holdersBoard Do not use the swing-up work surface as a cuttingYou will need side burner Install side burnerShown, do not push the trim piece in all Install the left end trim piece and swing-up workWay and do not add bolts yet You will need work surface Install the work surfaceDo not use the work surface as a cutting board Fill liquid propane cylinder Connection. Using a wrench could damageRegulator coupling and could cause a gas leak Closed. Close by turning clockwiseLeaks. Be sure there are no sparks or open Do not use an open flame to check for gasFlames in the area while you check for Leaks. Sparks or open flames will resultYou will need Thermometer Install the thermometerYou will need Bottom shelf To Extinguish LightingSummary lighting instructions are on the control panel Manual Lighting Lighting only the side burner Lighting the Side BurnerCooking CleaningStorage and/or Nonuse Removal of the LP cylinder Refilling the Liquid Propane CylinderImportant LP Cylinder Information Liquid Propane Cylinder To Connect the hose to the cylinderLiquid Propane LP Cylinders Safe handling tips for Liquid Propane Gas CylindersLiquid Propane Cylinder requirements Inspection and Cleaning of the Weber Spider Stopper Guards Annual MaintenanceMain Burner Cleaning Procedure General MaintenanceWeber Spider Stopper Guards Replacing Main Burners Crossover Ignition System Operations Flame is low when burner is on Barbecue temperature onlyBurners burn with a yellow or Orange flame, in conjunction withFlame is low in High position Side Burner does not lightFlame is very yellow Conjunction with the smell of gas
Top Page Image Contents