Monessen Hearth ILDV20PV, ILDV20NV, ILDV30NV manual Glass Frame Removal

Page 29

GLASS FRAME REMOVAL

ILDV20/ILDV30 Fireplace Insert

CAUTION

Always use gloves when handling broken glass.

WARNING

Make sure the glass panel edges do not touch any metal parts during thermal expansion.

GLASS FRAME REMOVAL

1.Carefully remove upper filigree by pulling straight out.

2.Remove glass frame from insert by releasing two latches on top of insert and lifting the door up and off the unit. Figure 34

3.Set glass frame aside.

4.Re-install in reverse order.

Latches

FP1942

Figure 34

Glass Frame Removal

83D0511

29

Image 29

Contents What to do if YOU Smell GAS Ildv Series Direct Vent Gas Fireplace InsertInstallation General Installation InformationVent Installation Insert InstallationOwner Important Safety InformationInstaller Non-utility gas wells. This Never connect unit to privateGas is commonly known as Wellhead gasListed Vented GAS Fireplace Heater Product features and code approvalProduct Specifications Orifice SIZES, Pressures and BTUs High ElevationsBefore You Start ILDV20NV ILDV20PV ILDV30NV ILDV30PVILDV20 ILDV30 Insert dimensionsInsert Applications General installation InformationInsert Clearances ClearancesMantel clearances Hearth RequirementsInsert Placement ZERO-CLEARANCE Metal Fireplace Requirements InstallationInstallation Precautions Vent installationVent Requirements Combustion which can create a safety hazard. Consult your Failure to adjust air shutter properly may lead to improperDealer or installer if you suspect an improperly adjusted Altitude ConsiderationsVent Configurations Remove Manifold and Attach to Flex Vent Manifold Removal and InstallationCheck gas type Insert InstallationTo liquid petroleum LP gas Insert installationUse pipe joint sealant that is resistant Check for gas leaks Check GAS PressureDo not use open flame to Hand Held Remote Control Remote Wall mounted SwitchDo not use the entire bag of rock wool to cover burner area Log placementInstalling Logs and Rock Wool Ember Material in Firebox Place Log #6 Place Log #5 Install Surround Surround installationWhat to do if YOU Smell GAS Operating InstructionsInitial lighting Never use an open flame to check for gas leakLighting pilot Approved leak testing methodPilot position Main burner switchLighting the burner Adjust the AIR Shutter Glass Frame Removal Glass Frame RemovalBlower Replacement 20ILDV 30ILDV Blower Parts ListCleaning glass Cleaning and MaintenanceRelight pilot. Refer to Maintenance Replacement Parts Replacement Parts Observed Problem Possible Cause Remedy TroubleshootingILDV20/ILDV30 Fireplace Insert Five Year Warranty Lifetime WarrantyBasic Warranty If Warranty Service is NeededAFUE% Mhsc