Kenmore 153.33298, 153.33296, 153.332870HA, 153.332990HA, 153.332861 Thermostat and GAS Supply Check

Page 36

Troubleshooting Guide (cont'd)

_,WARNINGJ

This troubleshootingguidehasbeen suppliedfor useby quali-J fled servicepersonnelwho havea completeunderstandingof

bothe ectricticandgas.

_i CAUTION

J

Label all wiring before disconnecting any wiring; to ensure

J

correct reconnection. Failure to follow this instruction

J

could cause improper and possible dangerous operation,

 

resulting in DEATH, SERIOUS BODILY INJURY, OR

 

PROPERTY DAMAGE.

 

THERMOSTAT AND GAS SUPPLY CHECK

No

Is gas being supplied

to the

Yes

 

thermostat?

 

 

I

]*lhrn "ON" gassuppl_

Is thermostat calling for heat? Run (hot) water from heater and set

adjustment button higher. Check

using a manometer at thermostat pressure tap. I

Yes

Is there a minimum gas pressure 4" W.C. for natural gas or 10"

W.C. for propane (L.R) gas?

 

 

 

i

I

Call gas company to increase gas

_,_

NO

J l

pressure.

!

 

 

Yes

 

 

 

 

I

GO TO "SYSTEMS CHECK" <

SECTION, PAGE 37.

36

Page 35 Page 37
Image 36
Page 35 Page 37
Contents For Your Safety What to do if YOU Smell GASModel Numbers Safety Precautions AwarningjLwarning AwarningSafety Precautions contd Rious Bodily INJURY, or Property DamageAwarning Contents DcmgPn%aticaoeProduct Specifications Customer ResponsibilitiesAdditional Tools Needed When Sweat Soldering Materials and Basic Tools NeededMaterials Needed Basic ToolsInstallation Instructions Removing the Old Water HeaterInstallation Instructions contd Installations in Areas Where Flammable LIQFacts to Consider About the Location Facts to Consider About the Location contd Combustion Air and VentilationVenting Clearances Property DamageVenting Through Roof- Clearances InletInches Top and one commencing Within 12 inches From Installation Instructions Installation CompletedContd Water PipingTemperature-Pressure Relief Valve II \ PROVIDEA6AIR \ GAP BetweenWiring USE Without Power CordFilling the Water Heater Water Heaters Equipped for ONE Type VoltageWiring contd USE Without Power Cord contdWiring Diagram Venting Warn I NGpreVenting Through AN Outside Wall ALL Models Venting System Example Installations for ALL Models ALL Models Optional 2VENT PipingPVC, ABS or Cpvc Schedule 40 vent piping DIA.VENT MAX. Length ElbowsII0 DIA.VENT Number of 90 DEG MAX. Length FT ElbowsPrecautions DIA.VENT Number of 90 DEGDIA.VENT Number MAX. Length FT ElbowsApproximate Setting Time For 2 to 3 Pipe JointsVenting Through a Roof ALL Models 3PVC, ABS or Cpvc Schedule 40 vent pipingALL Models Optional 2 Vent Piping Gas Piping GAS Piping with Flexible Connector Gas Piping contdSediment Trap GAS Piping with ALL Black Iron Pipe To GAS ControlInstallation Checklist Check for LeaksModel Rating Plate Before OperatingOperating Instructions Before the Water Heater will OperateOperation Operating Instructions contd Before Operating Propane L.P. GASControl Sequence HOT Surface Direct Ignition Check for LeaksWith an ignition device which automatically Temperature Regulation ContdService and Adjustment Tank Sediment CleaningBurner Cleaning Venting System InspectionTemperature-Pressure Relief Drain Valve Washer ReplacementDraining TEM Peratu RE-PRESSURE Discharge PipeTroubleshooting Guide Start Up ConditionsThermal Expansion Strange SoundsTroubleshooting Guide contd CondensationSMOKE/ODOR AIR in HOT Water FaucetsVenting Manual Reset Switch High Temperature Limit SwitchOperational Conditions contd Not Enough or no HOT WaterLeakage Checkpoints Thermostat and GAS Supply Check Error in the hot surface ignitorcircuit Systems Check¢Te= Blower will not run Condensation Water Leaks Leaking T&P HOT Water OdorsPage Economizer TM 6 Power Vent GAS Water Heater Model Numbers Parts Order ListParts Order List contd KEY NO. Part DescriptionParts Order List 153.332960 153.332970HA 153.332980 153.332990HA Sears Installation Service Master Protection Agreements
Top Page Image Contents