Manitowoc Ice S manual Water Trough, Water Distribution Tube Removal

Page 48

Maintenance	Section 4

3. Water Distribution Tube

!Warning

Removing the distribution tube while the water pump is running will allow water to spray from ice machine. Disconnect the electrical power to the ice machine and dispenser at the electric service switch box and turn off the water supply.

NOTE: Distribution tube thumbscrews are retained by o- rings to prevent loss. Loosen thumbscrews but do not pull thumbscrews out of distribution tube.

A

B

4.Water Trough

A.Depress tabs on right and left side of the water trough.

B.Allow front of water trough to drop as you pull forward to disengage the rear pins.

DEPRESS TABS

Water Distribution Tube Removal

A.Remove outer half of distribution tube by loosening the four (4) thumbscrews (o-rings retain thumbscrews to distribution tube).

B.Pull inner half of water distribution tube forward to release slip joint from water pump tubing connection.

4-8	Part Number 80-1620-3

Image 48

Contents

Model Ice Machines Read These Before Proceeding Personal Injury PotentialPage Manitowoc ICE, INC Table of Contents Table of Contents Section Ice Machine OperationSection Table of Contents Maintenance Section Before Calling For ServiceTable of Contents How to Read a Model Number Model NumbersIce Cube Sizes Self-Contained Remote Air-CooledGeneral Information Section Accessories Section General Information Model/Serial Number Location Model/Serial Number LocationWarranty Coverage Ice Machine Dimensions Ice Machine Dimension W Dimension D Dimension HGeneral S320/S420 AIR and WATER-COOLED ICE MachinesInstallation Instructions Section S600 AIR and WATER-COOLED ICE MachinesS600 Remote ICE Machines Width, Depth, and Height Dimensions Electrical and AuCS DimensionsIce Storage Bin Dimensions Bin Model Dimension a Dimension BS500/S850/S1000 Remote ICE Machines Inch 76 CM ICE Storage Bins Inch 56 CM ICE Storage BinsS1400/S1600/S1800 AIR and WATER-COOLED ICE Machines S1400 / S1800 Remote ICE MachinesInch 130 CM ICE Storage Bins B970Section Installation Instructions Location of Ice Machine Ice Machine Heat of RejectionAir-Cooled Baffle Leveling Leg and FootAir Baffle Section Installation Instructions Electrical Service VoltageFuse/Circuit Breaker Minimum Circuit AmpacityMaximum Breaker Size & Minimum Circuit Amperage Chart For United Kingdom Only Self Contained ICE Machine 115/1/60 or 208-230/1/60Self Contained ICE Machine 208-230/3/60 Self Contained ICE Machine 230/1/50Single Cooling Tower Applications Water-Cooled Models Water SupplyWater Inlet Lines Drain ConnectionsTypical Water Supply Drain Installation Water Supply and Drain Line SIZING/CONNECTIONSCondenser Bin DrainAir Temperature Around the Condenser Remote ICE Machines Refrigerant ChargeIce Machine Remote Single Line Set Circuit Condenser Line Set Discharge Line Liquid LineGuidelines for Routing Line Sets Routing Line SetsCalculating Remote Condenser Installation Distances Connecting a Line SET Remote Receiver Service ValveBackseating the Receiver Service Valve Lengthening or Reducing Line SET LengthsWarranty Internal Condenser VolumeHead Pressure Control Valve FAN MotorNON-MANITOWOC MULTI-CIRCUIT Condenser Sizing Chart Typical Single Circuit Remote Condenser InstallationSection Installation Instructions Installation Check List Additional Checks for Remote ModelsAuCS Automatic Cleaning System Section Ice Machine Operation Component IdentificationIce Machine Operation Section Sequence Of Operation Initial START-UP or START-UP After Automatic SHUT-OFFSafety Timers Harvest Sequence 5. Water PurgeHarvest Automatic SHUT-OFF 7. Automatic Shut-OffIce Machine Operation Section Operational Checks Water LevelICE Thickness Check Ice Thickness CheckWater Purge Adjustment Harvest Sequence Water PurgeIce Machine Operation Section Section Maintenance Exterior CleaningCleaning the Condenser Ice Machine InspectionMaintenance Section Water-Cooled Condenser Water Regulating ValveAlphaSan Straighten Bent Condenser FinsSection Maintenance Guardianf Guardianf Location GUARDIANf Sachet Replacement FrequencySachet INSTALLATION/REPLACEMENT Procedure Clean UP Procedure for Damaged Sachet Packet Maintenance Section Interior Cleaning and Sanitizing Cleaning Procedure Model Amount of Cleaner StepSanitizing Procedure Solution Type Water Mixed WithModel Amount of Sanitizer Removal of Parts for CLEANING/SANITIZING Water Curtain Water Curtain Removal Ice Thickness ProbeIce Thickness Probe Removal Water Distribution Tube Water TroughWater Distribution Tube Removal Water Level Probe Water PumpWater Pump Removal Dump Valve Disassembly Water Dump ValveEvaporator Tray Removal Drain Line Check ValveRemoving the Front Panels Water Inlet ValveSection Maintenance Removal from Service/Winterization SELF-CONTAINED AIR-COOLED ICE MachinesWATER-COOLED ICE Machines Remote ICE MachinesThis page Intentionally Left Blank Checklist Problem Possible Cause To CorrectBefore Calling For Service Section Safety Limit Feature