Jackson 200S, 200LT, 200B technical manual Parts Section Cantilever ARM/DOOR Assemblies

Page 36

SECTION 6: PARTS SECTION

CANTILEVER ARM/DOOR ASSEMBLIES

18, 22

18, 23

10, 11, 21

13

14

9

15, 16

18, 24

2 3

1

11

12

19

20

6

7

8

4

5

17, 28, 12	10, 11, 12, 13
3e	3d

3a

3c

3b

3f

200 Series Technical Manual

7610-100-45-00 Rev. E (02/10/2006)

31

Image 36

Contents Technical Manual Steam Heated ModelsPage Revision Made Applicable Details Date ECN 200 NB Nomenclature for the Models Covered in this ManualTable of Contents Section Description Specifications II. INSTALLATION/OPERATION InstructionsVII Electrical Diagrams DRAWING/PARTS SectionSection Specification Information Temperatures Operating Cycle SecondsTank Capacity Gallons Wash Pump CapacitySpecification Information Dimensions TOP ViewCorner Conversion TOP View Front Front ViewSpecification Information Table DimensionsSection INSTALLATION/OPERATION Instructions Raise Lower Frame with Adjustable Foot GND INSTALLATION/OPERATION Instructions Detergent Control INSTALLATION/OPERATION Instructions Operation Instructions INSTALLATION/OPERATION Instructions Operation Instructions Section Preventative Maintenance Preventative Maintenance Section Troubleshooting Section Troubleshooting Section Common Problems Problem Dishmachine will not run. No power to the unitProblem Water temperature is less than required Section Service Procedures Service Procedures Rinse Solenoid Valve Repair Parts KIT StepsPreparation Tools RequiredPrying open the coil wire cover Removing the valve bonnet After Maintenance Actions Special PartsService Procedures Vacuum Breaker Repair Parts KIT Set the cap to the sideRemoving the plunger Service Procedures Rinse Regulating Thermostat Replacement Service Procedures Rinse Regulating Thermostat Replacement Tightening the brass fitting Special Notes Contact InformationSection Parts Section Parts Section Control BOX Assembly JacksonQTY Description Parts Section Hood Assembly Single Piece Weldment Parts Section Cantilever ARM/DOOR Assemblies Parts Section Parts Section TUB Assembly See page Entitled Wash HEATERS/RINSE HeatersTub Weldment Not used on 200S Parts Section Rinse Tank Assembly 200B Parts Section Wash HEATERS/RINSE Heaters Rinse Heater 12 KWParts Section Motor Assembly Model Volts Phase Wash Motor AssemblyParts Section Frame Assembly Parts Section Incoming Fill PLUMBING/OUTLET Plumbing Water Pressure Regulator KIT Wprk Option Plumbing Complete Vacuum Breaker Assembly Parts Section Coil Assembly 200S Parts Section Incoming Steam Plumbing Assembly 200S Parts Section Wash & Rinse ARM/MANIFOLD Assemblies Exploded View of Wash & Rinse Spindle Assembly Parts Section Safety Door Interlock SDI Option FAN Load on Timer Output Parts Section Exhaust FAN Control OptionParts Section False Panel Installation False panel positioned in unitSection Electrical Schematics Electricalschematics 200/200B/200LT 208-230-460V, 50/60 HZ, Single & Three Phase200S 208-230-460V, 50/60 HZ, Single & Three Phase