Jackson 200S, 200B Table of Contents Section Description Specifications, DRAWING/PARTS Section

Page 5

TABLE OF CONTENTS

SECTION

DESCRIPTION

PAGE

I.

SPECIFICATIONS

 

 

Operating Capacities

2

 

Dimensions

3

 

Table Dimensions

4

II.INSTALLATION/OPERATION INSTRUCTIONS

 

Installation Instructions

6

 

Electrical Installation Instructions

7

 

Detergent Control

8

 

Operation Instructions

9

III.

PREVENTATIVE MAINTENANCE

12

IV.

TROUBLESHOOTING SECTION

14

V.SERVICE PROCEDURES

 

Solenoid Valve Replacement Kit

17

 

Vacuum Breaker Replacement Kit

21

 

Rinse Thermostat Replacement Kit

23

VI.

DRAWING/PARTS SECTION

 

 

Control Box Assembly

28

 

Hood Assembly

30

 

Cantilever Arm Assembly

31

 

Tub Assembly

33

 

Rinse Tank Assembly

35

 

Wash Heaters - Rinse Heaters

36

 

Motor Assembly

37

 

Frame Assembly

38

 

Incoming Plumbing / Outlet Plumbing Assembly

39

 

Solenoid Valve Repair Kit / Vacuum Breaker Repair Kit

41

 

Steam Coil Assembly

42

 

Incoming Steam Plumbing Assembly

43

 

Wash & Rinse Arms/Manifold Assemblies

44

 

Safety Door Interlock (SDI) Option

46

 

Exhaust Fan Control Option

47

 

False Panel Kit Option

48

VII.

ELECTRICAL DIAGRAMS

 

 

200/200B/200LT 208 - 230 - 460 V, 50/60 HZ, single/three phase

50

 

200S 208 - 230 - 460 V, 50/60 HZ, single/three phase

51

200 Series Technical Manual

7610-100-45-00 Rev. E (02/10/2006)

iii

Image 5
Contents Steam Heated Models Technical ManualPage Revision Made Applicable Details Date ECN Nomenclature for the Models Covered in this Manual 200 NBII. INSTALLATION/OPERATION Instructions Table of Contents Section Description SpecificationsVII Electrical Diagrams DRAWING/PARTS SectionSection Specification Information Operating Cycle Seconds TemperaturesTank Capacity Gallons Wash Pump CapacityTOP View Specification Information DimensionsCorner Conversion TOP View Front Front ViewTable Dimensions Specification InformationSection INSTALLATION/OPERATION Instructions Raise Lower Frame with Adjustable Foot GND INSTALLATION/OPERATION Instructions Detergent Control INSTALLATION/OPERATION Instructions Operation Instructions INSTALLATION/OPERATION Instructions Operation Instructions Section Preventative Maintenance Preventative Maintenance Section Troubleshooting Section Problem Dishmachine will not run. No power to the unit Troubleshooting Section Common ProblemsProblem Water temperature is less than required Section Service Procedures Steps Service Procedures Rinse Solenoid Valve Repair Parts KITPreparation Tools RequiredPrying open the coil wire cover Removing the valve bonnet Special Parts After Maintenance ActionsSet the cap to the side Service Procedures Vacuum Breaker Repair Parts KITRemoving the plunger Service Procedures Rinse Regulating Thermostat Replacement Service Procedures Rinse Regulating Thermostat Replacement Tightening the brass fitting Contact Information Special NotesSection Parts Section Jackson Parts Section Control BOX AssemblyQTY Description Parts Section Hood Assembly Single Piece Weldment Parts Section Cantilever ARM/DOOR Assemblies Parts Section See page Entitled Wash HEATERS/RINSE Heaters Parts Section TUB AssemblyTub Weldment Not used on 200S Parts Section Rinse Tank Assembly 200B Rinse Heater 12 KW Parts Section Wash HEATERS/RINSE HeatersModel Volts Phase Wash Motor Assembly Parts Section Motor AssemblyParts Section Frame Assembly Parts Section Incoming Fill PLUMBING/OUTLET Plumbing Water Pressure Regulator KIT Wprk Option Plumbing Complete Vacuum Breaker Assembly Parts Section Coil Assembly 200S Parts Section Incoming Steam Plumbing Assembly 200S Parts Section Wash & Rinse ARM/MANIFOLD Assemblies Exploded View of Wash & Rinse Spindle Assembly Parts Section Safety Door Interlock SDI Option Parts Section Exhaust FAN Control Option FAN Load on Timer OutputFalse panel positioned in unit Parts Section False Panel InstallationSection Electrical Schematics 200/200B/200LT 208-230-460V, 50/60 HZ, Single & Three Phase Electricalschematics200S 208-230-460V, 50/60 HZ, Single & Three Phase