Jackson Electricalschematics, 200/200B/200LT 208-230-460V, 50/60 HZ, Single & Three Phase

Page 55

SECTION 7: ELECTRICALSCHEMATICS

200/200B/200LT 208-230-460V, 50/60 HZ, SINGLE & THREE PHASE

Dashed White/Blue wire is added for Sani-sure Option.

Sani-sure can only be installed on machines with booster option.

9905-105-01-12

200 Series Technical Manual

7610-100-45-00 Rev. E (02/10/2006)

50

Image 55

Contents Steam Heated Models Technical ManualPage Revision Made Applicable Details Date ECN Nomenclature for the Models Covered in this Manual 200 NBDRAWING/PARTS Section Table of Contents Section Description SpecificationsII. INSTALLATION/OPERATION Instructions VII Electrical DiagramsSection Specification Information Wash Pump Capacity TemperaturesOperating Cycle Seconds Tank Capacity GallonsFront View Specification Information DimensionsTOP View Corner Conversion TOP View FrontTable Dimensions Specification InformationSection INSTALLATION/OPERATION Instructions Raise Lower Frame with Adjustable Foot GND INSTALLATION/OPERATION Instructions Detergent Control INSTALLATION/OPERATION Instructions Operation Instructions INSTALLATION/OPERATION Instructions Operation Instructions Section Preventative Maintenance Preventative Maintenance Section Troubleshooting Section Problem Dishmachine will not run. No power to the unit Troubleshooting Section Common ProblemsProblem Water temperature is less than required Section Service Procedures Tools Required Service Procedures Rinse Solenoid Valve Repair Parts KITSteps PreparationPrying open the coil wire cover Removing the valve bonnet Special Parts After Maintenance ActionsSet the cap to the side Service Procedures Vacuum Breaker Repair Parts KITRemoving the plunger Service Procedures Rinse Regulating Thermostat Replacement Service Procedures Rinse Regulating Thermostat Replacement Tightening the brass fitting Contact Information Special NotesSection Parts Section Jackson Parts Section Control BOX AssemblyQTY Description Parts Section Hood Assembly Single Piece Weldment Parts Section Cantilever ARM/DOOR Assemblies Parts Section See page Entitled Wash HEATERS/RINSE Heaters Parts Section TUB AssemblyTub Weldment Not used on 200S Parts Section Rinse Tank Assembly 200B Rinse Heater 12 KW Parts Section Wash HEATERS/RINSE HeatersModel Volts Phase Wash Motor Assembly Parts Section Motor AssemblyParts Section Frame Assembly Parts Section Incoming Fill PLUMBING/OUTLET Plumbing Water Pressure Regulator KIT Wprk Option Plumbing Complete Vacuum Breaker Assembly Parts Section Coil Assembly 200S Parts Section Incoming Steam Plumbing Assembly 200S Parts Section Wash & Rinse ARM/MANIFOLD Assemblies Exploded View of Wash & Rinse Spindle Assembly Parts Section Safety Door Interlock SDI Option Parts Section Exhaust FAN Control Option FAN Load on Timer OutputFalse panel positioned in unit Parts Section False Panel InstallationSection Electrical Schematics 200/200B/200LT 208-230-460V, 50/60 HZ, Single & Three Phase Electricalschematics200S 208-230-460V, 50/60 HZ, Single & Three Phase