WhisperKool 5000 owner manual Quick Start Guide

Page 12

QUICK START GUIDE

This guide is meant to serve as a quick reference for installation of the WhisperKOOL unit. The remainder of this Owner’s Manual will provide more detailed information and instructions.

Upon receiving the WhisperKOOL unit:

1.Inspect the unit before installation. If damage is found, please contact your distributor or WhisperKOOL Customer Service at 1.800.343.9463 ext 799.

2.The unit should remain in an upright position for 24 hours prior to operation.

3.The WhisperKOOL unit requires a dedicated 115-volt20-amp circuit. Use a surge protector with the WhisperKOOL unit. Do not use a GFI (Ground Fault Interrupter) line.

4.For your convenience, the WhisperKOOL unit has two power inlets, one on the side of the unit and the other on the back. Use the selector switch, located on the right side of the unit, to select the inlet you would like to use.

5.The unit is designed to gently cool down the temperature of the cellar over time by cycling cooler and cooler air throughout. Test the unit prior to installation. Operate unit for twenty minutes. While the unit is running and working properly, the air discharged from the front should be 10 - 15°F cooler than the air in the room. This means that in an environment where the air is 80°F, the unit will discharge air that is 65-70°F.

6.It is REQUIRED to install a drain line to remove condensation from the unit.

7.The WhisperKOOL unit is intended for use in properly designed and constructed wine cellars. Hire a professional wine storage consultant with a valid contractor’s license to build your wine cellar. Refer to the “How to Build a Wine Cellar” video available on the WhisperKOOL website at www.whisperkool.com.

8.Install the foam strips along the inside edge of the unit’s flange to assure a proper seal against the wall.

Never try to open the WhisperKOOL unit, repair it yourself, or use a service company without WhisperKOOL’s authorization. This will void your warranty.

If you encounter a problem with your WhisperKOOL unit, please refer to the Troubleshooting Guide on page 36. If you have any further questions, concerns, or need assistance, please contact WhisperKOOL Customer Service at 1.800.343.9463 ext. 799. Please be sure all testing has been completed prior to contacting Customer Service. Please have your results ready for your representative.

Page 10

EXti 110111

Page 11 Page 13
Image 12
Page 11 Page 13
Contents Extreme 5000 Page Table of Contents Quick Reference Guide Front / Side ViewFully Ducted Front / Side View 8000 / 8000 Rear / Side View Compressor Access Panel Standard Controller Layout Unit Specifications FAN Speed ReferenceModel Low Med HighIntroduction Review the Packing Slip to Verify Contents Check the Box for the following contents 5000Receiving & Inspecting the Unit Receiving and Inspecting the UnitQuick Start Guide Preparing the Wine Cellar InsulationVapor Barrier Mounting the Unit Unobstructed AirflowDoor and Door Seal Air Intake Cellar Wall Ambient Temperature Factor Using any other ducting system will void the warrantyVentilation Exhaust FanPRE-INSTALLATION Electrical NeedsElectrical Inlets Preparing the Installation Location Minimum Tools NeededPreparing the System for Installation Mounting Bracket InstallationSingle Piece Mounting Bracket Applying Insulation Tape8000 Mounting FlangesExterior Grille Installation Non-Flush InstallationFlush Installation Optional Exterior Grille8000 THROUGH-THE-WALL Installation Installing the SystemBack of Unit Ducting Overview Use of DuctworkGeneral Duct Recommendations Location of Supply and Return GrillesDucting Configurations Half Duct Configuration Wine CellarThree-Quarter Duct Configuration Wine Cellar Adjacent RoomFully Ducted Attic Mounted SystemInstalling the Duct Plenums Remote Controller Installation Mounting Bracket Failure to install the drain line voids the warranty Drain LineCondensation Drain Line Tube Drain LineLiquid Measuring Thermostat System Self-Calibrating ProbeLiquid Measuring Thermostat System To Use the thermostatMulti FAN Speed Control 59/59 60/6157/57 System Operation Button/Symbol Normal Functions Standard Controller FunctionsUp and Down ArrowsAlarm Anti-FrostPage Standard Remote Controller Functions Button Normal FunctionsCheck Evaporator Probe connection at green terminal block on Cpsm Mode Remote Wire Schematic Maintenance Schedule Unit does not run/power up Possible Cause Solution Cellar Temperature is to Warm Possible Cause SolutionUnit leaks water Possible Cause Solution Unit runs but does not cool Possible Cause SolutionPossible Cause Solution Compressor short cycles Possible Cause SolutionAccessories for Cooling Units Contact WhisperKOOL Customer ServiceTechnical Assistance Condensate Pump KitInstallation Terms and Conditions WhisperKOOL Cooling SystemProduct Installation Requirements Model Serial NumberA Installed by Date Sales and USE TAXPage Page WhisperKOOL
Top Page Image Contents