Marathon
RJ-100SC, RJ-88SC, RJ-250VL, RJ-250SC
installation manual
Power Unit Standard 10 HP
Troubleshooting
Specifications
Install
Parts list
Charts
RAM Control Timer Adjustment
Wire Sizes
Warranty
Maintenance
Dock Access Gate & Hopper
Page 26
2 MAINTENANCE
POWER UNIT - STANDARD 10 HP
2-13
Page 25
Page 27
Image 26
Page 25
Page 27
Contents
Play IT Safe
Contents
Operation
Introduction
Wastec
Specifications
Side View
PRE-OPERATION Instructions
Only Authorized Personnel Should be Allowed Inside
Emergency Stop Control Description for 88SC, 100SC, & 250SC
Keyed Start Switch Reverse
Operator Station
Control Description for 250VL
Case of Emergency
Operating Instructions for RJ-250VL
Manual Override Instructions RAM Stop Rear only RJ-250VL
Optional Controls
Decals for RJ-88SC, RJ-100SC, RJ-250SC, or RJ-250VL
Remote Power Unit
THRU-THE-WALL
Optional Loading Configurations
Dock Access Gate & Hopper
Security Chute
Hydraulic Tailgate HT Units
Rear View
Maintenance
LOCK-OUT & TAG-OUT Instructions
Periodic Maintenance
Pressure Settings Relief
Procedures
Pressure Setting
Setting
RAM Control Timer Adjustment
Printe D Circuit Board Locate D I N Motor Control Panel
Cylinder Removal Instructions
MULTI-CYCLE Timer Adjustment Option
Warranty and Service on Motors
RAM Stop Forward Option
Standard System Operating CHARACTERISTICS, 5 hp & 10 hp
Principles of Operation
Door Seal on Door
Tailgate Seal Replacement
Front View
Section A-A
Fuses and Circuit Breakers
Charts
Timer Settings
Wire Sizes
Length Size
Parts List
Part Description
Motor Control Panel Typical
Power Unit Standard 5 HP
Power Unit Standard 10 HP
Hydraulic Schematic Typical
TROUBLE-SHOOTING Chart
Problem Cause Solution
Pump Makes NOISE-SOUNDS
Container Guides
Concrete PAD Requirements
Concrete PAD
CHUTE-FED Installation
Steel Installation Procedures
Dock Installation
Decals
Electrical & Hydraulic Installation
Remote Power Pack Installation
START-UP Instructions
Pushbutton Operator Station
Electrical Connections
TOP View Compactor
THROUGH-THE-WALL Power Unit Installation
Power Unit
Hauler Instructions General
See the Next page for Door and Latch Operation Instructions
Latch Side View Container
Hauler Instructions DOOR/LATCH Operation
Auto Relatch
For Optional HT Units
Instructions for Using Maintenance BAR
Body Between the Tailgate and the Container
Hauler Instructions Liquid Removal For Optional SL Units
Top
Page
Image
Contents