Generac Power Systems 5254, 5252, 5251, 5255, 5253 owner manual Battery Charger

Page 36

Section 8 — Electrical Data

Air-cooled Generators

Electrical Schematic – 10, 13 & 16kW, V-Twin – Drawing No. 0F7823

0	3
	2
	1	BATTERY
		BATTERY
		CHARGER
13		1	224B
		1	224B
0		2	225B
			13
0			0	0	18
0			0	0
			15		86
			15
					85
SCR
			16
56			56
				0

			11
			22
ELECTRONIC			4
VOLTAGE				4
REGULATOR			0
			6
			2
				GOVERNOR
				ACTUATOR
MANUAL		AUTO	194
			194
			15A
194	15A
	194			15A
				15A
	SW1
15	239
				239
				15
15		SW2
				15B
J2		J1	1	15A
J2		J1	2	4
			3	23
			4	86
			5	18
			6
			7
			8	LC1
CONTROL			9	56
CONTROL			10	224
PRINTED CIRCUIT			11	239
BOARD			12	85
BOARD			13
			13
			14
			15	LC2
			16	14
			17	225
			18
			19	15B
			20	0
			21
			22
			23	90

224B

16

0

13

225B

18

86

85

4

13

6

2

16

14

			22	11
											0
											0
											11
											22
194	4	56	15	0							LC1
											LC1
											LC2
											LC2
											0
											23
											194
				F1	13						225B
				15							224B
					23	18	86	LC1	85	LC2	0

224

14

14	14
	225

14

CS 14

34

Image 36

Contents Listed Introduction Authorized Dealer LocationPost Installation Start-up Adjustments MaintenanceTroubleshooting Introduction Inside Front Cover Warning   Electrical Hazards  ‹ Standards IndexUNPACKING/INSPECTION Protection SystemsBreaker for Bedrooms Generator 7kW, Single Cylinder GH-410 EngineSpecifications ‹ 1.5.1 Generator‹ 1.5.2 Engine System SET LED Fuel Requirements RecommendationsFuel Consumption ‹ 1.8.1 BTU Flow Requirements Natural GASReconfiguring the Fuel System ‹ 1.9.1 7 KW, 410CC Engine‹ 1.9.2 10, 13 and 16KW, V-TWIN Engines Location ‹ 1.10.1 GeneratorBattery Requirements Battery Installation‹ 1.10.2 Transfer Switch 10.2.1 7, 10, 13, and 16 kW Units if equippedBattery 10 Battery Cable ConnectionsCheck Transfer Switch Operation Before Initial START-UPElectrical Checks Generator Tests Under Load Checking Automatic Operation7KW Natural GAS only Engine Governor Adjustment ‹ 2.7.1 7 KW Units‹ 3.1.1 Auto Position ‹ 3.1.3 Manual PositionAutomatic Transfer Operation Sequence of Automatic OperationManual Transfer Operation ‹ 3.1.4 Choke OperationSetting the Exercise Timer ‹ 3.4.2 Transfer Back to Utility Power Source‹ 3.6.1 LOW OIL Pressure Switch ‹ 3.6.2 High Temperature Switch‹ 3.6.3 Overcrank Approximate Crank Cycle Times‹ 3.6.6 LOW Battery Checking the Engine OIL LevelFuses ‹ 3.6.5 RPM Sensor FailureChanging the Engine OIL ‹ 4.3.1 OIL Change Intervals‹ 4.3.2 Engine OIL Recommendations Spark Plugs ‹ 4.4.1 7, 13, and 16KW Generators‹ 4.4.2 10KW Generators Battery Maintenance Valve ClearanceCooling System 11 Cooling Vent LocationsOUT of Service Procedure ‹ 4.11.2 Return to Service‹ 4.11.1 Removal from Service Corrosion ProtectionService Schedule Be performed by the nearest Authorized DealerTroubleshooting Guide Problem Cause CorrectionAir-cooled Generators Air-cooled Generators Air-cooled Generators Mounting Dimensions Electrical Data Engine Wiring Customer Connection Battery Charger Engine Alternator Engine Wiring Stator Electronic Voltage Regulator Manual Auto Scsm Neutral Electrical Data Electrical Data Sheet Metal PAINT/MATERIAL Code Legend Part NO. QTY. Description Air-cooled Generators Control Panel Drawing No F9695-C QTY Description Exploded Views and Parts Lists BOX Load Center Exploded Views and Parts Lists Description QTY Exploded Views and Parts Lists Washer Flat M8 5/16 Exploded Views and Parts Lists Crankcase Exploded Views and Parts Lists Intake Adapter Exploded Views and Parts Lists PIN, Piston D20 Exploded Views and Parts Lists SCREW, Taptite M6-1.0X8 Yellow Chrome Air-cooled Generators 7kW, GN-410 Engine Drawing No F9422-B ADAPTOR, Engine Exploded Views and Parts Lists ADATOR, Engine 7KW CASTING, Twin Regulator Housing 7KW Exploded Views and Parts Lists Brkt Regulator Mounting Your Warranty Rights and Obligations MANUFACTURER’S Emission Control System Warranty CoveragePURCHASER’S/OWNER’S Warranty Responsibilities Emission Control System Warranty Emission Related Parts Include the FollowingGenerac Power Systems Standard Limited Warranty for