Generac Power Systems 5253, 5252, 5254, 5251, 5255 owner manual Brkt Regulator Mounting

Page 69

 

 

 

 

Section 9 — Exploded Views and Parts Lists

 

 

 

 

 

 

 

 

 

 

 

 

Air-cooled Generators

 

 

 

 

13 & 16kW, GT-990 Regulator – Drawing No. 0F9426

 

ITEM

PART NO.

QTY.

DESCRIPTION

 

1

0F9285

1

CASTING, TWIN REGULATOR HOUSING

 

2

0F5022

1

SOLENOID COIL, 12VDC

 

3

0C4647

2

GASKET , SOLENOID

 

4

0D4166

1

PLUNGER, LP REGULATOR ASSEMBLY

 

5

0F8096

1

BRKT REGULATOR MOUNTING 990

 

6

022145

4

WASHER FLAT 5/16-M8

 

7

022129

4

WASHER LOCK 5/16-M8

 

8

0F4795

8

SCREW PPHM SEMS M4-0.7 X 10

 

9

045771

2

NUT HEX M8-1.25

 

10

0C6606

2

BARBED STRAIGHT ½ NPT x ½

 

11

042907

2

SCREW HHC M8-1.25 X 16

 

12

026915A

1

NIPPLE CLOSE ¾ X 1.375 WITH VIBRA SEAL

 

13

0C5761

2

LEVER, REGULATOR

 

14

0C5968

2

SUPPORT, INLET SEAL

 

15

0C6066

2

SEAL, INLET

 

16

0C5759

2

PIN, PIVOT ARM

 

17

0C5764

2

SPRING, REGULATOR

 

18

070728

4

SCREW, PFHMS M3-0.5 x 5

 

19

0C6069

2

GASKET, DIAPHRAGM

 

20

0F9189

2

COVER, TWIN REGULATOR

 

21

045764

16

SCREW, TAPTITE M4X8 BP

 

22

0C6731

2

RIVET, POP .118 X .125

 

23

0C6067

2

SUPPORT, DIAPHRAGM

 

24

0C4706

2

DIAPHRAGM, TWIN REGULATOR

 

25

0C6068

2

CAP, DIAPHRAGM SUPPORT

 

26

0C4643A

2

INLET, TWIN REGULATOR 11.11 DIA.

 

27

072683A

3

PLUG STD PIPE 1/8 SOCKET HEAD

 

28

049226

4

WASHER, LOCK, M5

 

29

0D3308

4

WASHER, FLAT M3 X 10mm O.D.

 

30

051713

4

WASHER, FLAT, M5

 

31

0F8979

1

SOLENOID COVER PLATE

 

32

051716

4

NUT HEX M5-0.8

 

33

0E9533

1

SOLENOID ADAPTER

 

34

0E9534

1

ASSY, FUEL SYSTEM PLENUM

 

35

0E9535

1

PLENUM GASKET

67

Image 69
Contents Listed Authorized Dealer Location IntroductionMaintenance Post Installation Start-up AdjustmentsTroubleshooting Introduction Inside Front Cover Warning  ‹ Standards Index  Electrical Hazards UNPACKING/INSPECTION Protection SystemsBreaker for Bedrooms 7kW, Single Cylinder GH-410 Engine GeneratorSpecifications ‹ 1.5.1 Generator‹ 1.5.2 Engine Fuel Requirements Recommendations System SET LEDFuel Consumption ‹ 1.8.1 BTU Flow Requirements Natural GASReconfiguring the Fuel System ‹ 1.9.1 7 KW, 410CC Engine‹ 1.9.2 10, 13 and 16KW, V-TWIN Engines ‹ 1.10.1 Generator LocationBattery Installation Battery Requirements‹ 1.10.2 Transfer Switch 10.2.1 7, 10, 13, and 16 kW Units if equipped10 Battery Cable Connections BatteryCheck Transfer Switch Operation Before Initial START-UPElectrical Checks Generator Tests Under Load Checking Automatic Operation7KW Natural GAS only ‹ 2.7.1 7 KW Units Engine Governor Adjustment‹ 3.1.3 Manual Position ‹ 3.1.1 Auto PositionSequence of Automatic Operation Automatic Transfer OperationManual Transfer Operation ‹ 3.1.4 Choke Operation‹ 3.4.2 Transfer Back to Utility Power Source Setting the Exercise Timer‹ 3.6.2 High Temperature Switch ‹ 3.6.1 LOW OIL Pressure Switch‹ 3.6.3 Overcrank Approximate Crank Cycle TimesChecking the Engine OIL Level ‹ 3.6.6 LOW BatteryFuses ‹ 3.6.5 RPM Sensor FailureChanging the Engine OIL ‹ 4.3.1 OIL Change Intervals‹ 4.3.2 Engine OIL Recommendations Spark Plugs ‹ 4.4.1 7, 13, and 16KW Generators‹ 4.4.2 10KW Generators Valve Clearance Battery Maintenance11 Cooling Vent Locations Cooling System‹ 4.11.2 Return to Service OUT of Service Procedure‹ 4.11.1 Removal from Service Corrosion ProtectionBe performed by the nearest Authorized Dealer Service ScheduleProblem Cause Correction Troubleshooting GuideAir-cooled Generators Air-cooled Generators Air-cooled Generators Mounting Dimensions Electrical Data Engine Wiring Customer Connection Battery Charger Engine Alternator Engine Wiring Stator Electronic Voltage Regulator Manual Auto Scsm Neutral Electrical Data Electrical Data Sheet Metal PAINT/MATERIAL Code Legend Part NO. QTY. Description Air-cooled Generators Control Panel Drawing No F9695-C QTY Description Exploded Views and Parts Lists BOX Load Center Exploded Views and Parts Lists Description QTY Exploded Views and Parts Lists Washer Flat M8 5/16 Exploded Views and Parts Lists Crankcase Exploded Views and Parts Lists Intake Adapter Exploded Views and Parts Lists PIN, Piston D20 Exploded Views and Parts Lists SCREW, Taptite M6-1.0X8 Yellow Chrome Air-cooled Generators 7kW, GN-410 Engine Drawing No F9422-B ADAPTOR, Engine Exploded Views and Parts Lists ADATOR, Engine 7KW CASTING, Twin Regulator Housing 7KW Exploded Views and Parts Lists Brkt Regulator Mounting Your Warranty Rights and Obligations MANUFACTURER’S Emission Control System Warranty CoveragePURCHASER’S/OWNER’S Warranty Responsibilities Emission Related Parts Include the Following Emission Control System WarrantyGenerac Power Systems Standard Limited Warranty for