Briggs & Stratton 7800886, BTXPV22725E Troubleshooting, Problem Probable Cause Corrective Action

Page 22

Troubleshooting

PROBLEM			PROBABLE CAUSE					CORRECTIVE ACTION
Engine Will Not Start	1. Fuel tank empty.						1.	Fill fuel tank with fresh fuel.
	2.	Spark plug wire disconnected.					2.	Place spark plug wire onto spark plug.
	3.	Wiring harness disconnected.					3.	Connect wiring harness.
	4.	Battery dead.					4.	Charge or replace battery.
Engine Stalls or Loses	1. Blade control is released or is not being held						1.	Blade control should be held securely against
Power After Running	securely against handle.						handle at all times during operation.
	2.	Fuel tank empty.					2.	Fill with fuel to proper level.
	3.	Engine pre-cleaner and/or air cleaner dirty.					3.	Clean or replace precleaner and/or air clean-
							er.
	4.	Spark plug fouled or gap set improperly.					4.	Service spark plug.
	5.	Water, debris or stale fuel in fuel system.					5.	Drain and clean fuel system.
Excessive Vibration	1. Damaged, out of balance or bent mower						1.	Contact authorized dealer.
	blade.
	2.	Loose blade components.					2.	Contact authorized dealer.
	3.	Loose or missing air lift (if equipped).					3.	Contact authorized dealer.
	4.	Lumpy or frayed belt.					4.	Contact authorized dealer.
Mower Will Not Move/	1. Build-up of debris on or around d ive						1.	Clean debris.
Loss Of Traction	components.
	2.	Transmission cable adjus ment required.					2.	Adjust ransmission cable.
	3.	Drive belt requires replacement.					3.	Contact authorized dealer.
	4.	Damaged transmissi			n.		4.	Contact authorized dealer.
Cutting Grass	1. Cutting height			l w	r high.		1.	Adjust cutting height.
Improperly
Improperly	2.	Forward speed too fast.					2.	Adjust to a slower speed.
	2.	Forward speed too fast.					2.	Adjust to a slower speed.
	3.	Cutting blade dull or damaged.					3.	Contact authorized dealer.
			Not
Poor Grass Discharge	1. Forward speed too fast.						1.	Adjust to a slower speed.
	2.	Grass is wet.					2.	Mow when grass is dry.
	3.	Excessively worn or damaged blade.					3.	Contact authorized dealer.
	4.	Build up of grass clippings and debris under					4.	Clean deck.
	deck.
	5.	Improper blade installed				deck.	5.	Contact authorized dealer.
	6.	Blade installed improperly on deck.					6.	Contact authorized dealer.
			Reproduction
Oil Leaking	1. Loose dipstick.						1.	Make sure dipstick/oil filler cap is securely in
							place.
	2.	Loose drain plug.					2.	Check and tighten drain plug.
	3.	Oil level is overfilled.					3.	Drain excess oil.
	4.	Damaged oil seals.					4.	Contact authorized dealer.

22	www.brutepower.com

Image 22

Contents Not For Not ErenceTable of Contents Operator Safety Operating SafetyMoving Parts Protection for Children Preparation From Previous ColumnSafe Handling of Gasoline Operation From Previous From Previous ColumnInstructions can result in serious bodily injury or Operator Safety Safety and Operation DecalsLowed. Not following these important warnings DeathReproduction Explanation of Operati DecalsFeatures and Controls Orf Not ReproductionSet Up the Starter Rope Handle Assembly Unpack the MowerRaise the Handle Assembly Assemble the Grass BagImportant Mower is shipped without oil Operation Before StartingOil Recomme datio s Engine. Failure to add oil before starting will resultStopping the Mower Starting the MowerPropelling the Mower Fuel RecommendationsOperation Cutting Height Adjustment Mulching OperationInstalling the Discharge Deflector Installing the Grass Bag OperationOperation Charging the Battery 7800887Maintenance Maintenance Chart Emissions ControlMaintenance Change Engine Oil Service Air FilterWashout Port Check Safety Interlock System MaintenanceClean Debris Off Mower Within 3 secondsMaintenance Drive Control Adjustment Adjusting the drive cableMaintenance Storage Procedure Fuel SystemTroubleshooting Problem Probable Cause Corrective ActionWarranty Period WarrantiesReproductionOn Your Small Off-Road Engine Emissions Label Slope Guide Mower Specifications AllEngine Manual del operador Ciones para consultarlas en el futuro Índice Lea el manual Seguridad del usuarioManejar el equipo con seguridad NiñosAcumulación de desechos Piezas móvilesObjetos tirados Combustible y mantenimientoProteja a LOS Niños Preparación Continuación de la columna previaManipulación Segura DE LA Funcionamiento Gasolina Continuación de la página anteriorSeguridad del usuario Etiquetas transparentes de Seguridad y funcionamientoEtas de funcionamiento Explicación del significado de las etiqCaracterísticas y controles ImportanteEnsamblaje de la bolsa para Montaje Desembalaje del cortacéspedLevantamiento del conjunto de La manilla Hie baFuncionamiento Antes de empezar RecomendaciPropulsión del cortacésped FuncionamientoEncendido del cortacésped Detención del cortacéspedAdvertencia 18 cm 10,16 cm Funcionamiento Carga de la batería La batería de este cortacésped está sellada y no necesitaMantenimiento Tabla de mantenimiento Control de emisionesAceite’. No llene el depósito en exceso Limpieza de los desechos del cortacésped Mantenimiento Revisar el sistema de bloqueo de seguridadPuerto de deslave Mantenimiento Ajuste del control de la transmisión Ilustración 19 Ajuste del cable de guiadoMantenimiento Procedimiento de almacenamiento Sistema de combustibleSolución de problemas Problema Causa Probable Acción CorrectorasGarantías Elemento Uso de consumo Uso comercialAbril Guía DE Inclinaciones Sensor de InclinaciónCortacésped Especificaciones TodosMotor