Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
24-Hour Service Hotline
8195895
Page
the fryer under a hood. Questions? Call the Dean Service Hotline at
DANGER
from slips or contact with the hot oil DANGER
other cooking appliance DANGER
TABLE OF CONTENTS
Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
TABLE OF CONTENTS CONT
Page #
THIS PAGE INTENTIONALLY LEFT BLANK
1.3 Service Information
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
1.1 After Purchase
1.2 Ordering Parts
1.4 Safety Information
1.5 Service Personnel
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
Example of a CAUTION box
1.5.1 Definitions cont
B. Qualified Installation Personnel
C. Qualified Service Personnel
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
THIS PAGE INTENTIONALLY LEFT BLANK
2.1 Receiving and Unpacking Equipment
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
2.2 General
2.2 General cont
2.3 Principles of Operation
2.4 Rating Plate
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
2.5 Pre-Installation
this chapter
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
DANGER
2.6 Equipment Installed at High Altitudes
2.5 Pre-Installation cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
2.7 Air Supply and Ventilation
2.7 Air Supply and Ventilation cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
DANGER
THIS PAGE INTENTIONALLY LEFT BLANK
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.1 Installing the Fryer
3.2 Leg and Caster Installation
movement to avoid damage and possible bodily injury DANGER
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.2 Leg and Caster Installation cont
3.3 Leveling the Fryer
before installing the casters
3.3 Leveling the Fryer cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
E. Installing Optional Swivel Casters
3.4 Gas Connections
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.3 Leveling the Fryer cont
DANGER
3.4 Gas Connections cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
Supply Line Specifications
Recommended Gas Supply Line Sizes
damage to the fryer’s gas piping and gas valves
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.4 Gas Connections cont
Rigid Connections
new connections
Personal injury may result
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
E. Flexible Couplings, Connectors and Casters
3.5 Adjustments/Adaptation To Different Gases
GAS SUPPLY FOR WHICH IT IS NOT CONFIGURED
defined in Section 1.5 of this manual
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.6 Gas Inputs
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.7 Gas Conversion Procedures
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.7 Gas Conversion Procedures cont
3.8 Gas Conversion Components
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
Natural Gas to Propane Kit
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.9 Electrical Connections
DANGER
4.1 Initial Start-up
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
DANGER
4.1.1 Pilot Lighting Procedures, Standing Pilot Only
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
4.2 Boil-Out Procedure
4.2.1 Thermostat-Equipped Fryers
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
DANGER
contents of the frypot
will damage the heating tubes and frypot, and void the warranty
4.3 Final Preparation
4.2.1 Thermostat-Equipped Fryers cont
B. When using a solid shortening, first melt it in a suitable container, or cut it into small pieces and pack it below the heat tubes, between the tubes and on top of the tubes, leaving no air spaces around the tubes. Do not disturb or bend the sensing bulbs
instructions provided with the filtration equipment
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
THIS PAGE INTENTIONALLY LEFT BLANK
5.1 General
5.1.1 Daily
5.1.2 Weekly
result
CHAPTER 5 PREVENTATIVE MAINTENANCE 5.1.3 Periodic/ Annual
See filtration manual for filtration maintenance procedures
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE
5.1.4 Stainless Steel Care DANGER
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
6.1 General
6.2 Pilot Burner Malfunction
DANGER
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
6.3 Main Burner Malfunctions
6.5 Recommended Spare Parts
6.4 Wiring Diagrams
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
SERVICE HOTLINE
Dean, 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana
Shipping Address 8700 Line Avenue, Shreveport, Louisiana
FAX Parts