24-Hour Service Hotline
Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
8195895
Page
DANGER
the fryer under a hood. Questions? Call the Dean Service Hotline at
from slips or contact with the hot oil DANGER
other cooking appliance DANGER
Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
TABLE OF CONTENTS
TABLE OF CONTENTS CONT
Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
Page #
THIS PAGE INTENTIONALLY LEFT BLANK
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
1.3 Service Information
1.1 After Purchase
1.2 Ordering Parts
1.5 Service Personnel
1.4 Safety Information
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
Example of a CAUTION box
B. Qualified Installation Personnel
1.5.1 Definitions cont
C. Qualified Service Personnel
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
THIS PAGE INTENTIONALLY LEFT BLANK
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
2.1 Receiving and Unpacking Equipment
2.2 General
2.3 Principles of Operation
2.2 General cont
2.4 Rating Plate
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
this chapter
2.5 Pre-Installation
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
DANGER
2.5 Pre-Installation cont
2.6 Equipment Installed at High Altitudes
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
2.7 Air Supply and Ventilation cont
2.7 Air Supply and Ventilation
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
DANGER
THIS PAGE INTENTIONALLY LEFT BLANK
3.1 Installing the Fryer
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.2 Leg and Caster Installation
movement to avoid damage and possible bodily injury DANGER
3.2 Leg and Caster Installation cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.3 Leveling the Fryer
3.3 Leveling the Fryer cont
before installing the casters
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
E. Installing Optional Swivel Casters
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.4 Gas Connections
3.3 Leveling the Fryer cont
DANGER
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.4 Gas Connections cont
Supply Line Specifications
Recommended Gas Supply Line Sizes
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
damage to the fryer’s gas piping and gas valves
3.4 Gas Connections cont
Rigid Connections
Personal injury may result
new connections
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
E. Flexible Couplings, Connectors and Casters
GAS SUPPLY FOR WHICH IT IS NOT CONFIGURED
3.5 Adjustments/Adaptation To Different Gases
defined in Section 1.5 of this manual
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.6 Gas Inputs
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.7 Gas Conversion Procedures
3.8 Gas Conversion Components
3.7 Gas Conversion Procedures cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
Natural Gas to Propane Kit
3.9 Electrical Connections
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
DANGER
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
4.1 Initial Start-up
DANGER
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
4.1.1 Pilot Lighting Procedures, Standing Pilot Only
4.2.1 Thermostat-Equipped Fryers
4.2 Boil-Out Procedure
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
DANGER
will damage the heating tubes and frypot, and void the warranty
contents of the frypot
4.3 Final Preparation
4.2.1 Thermostat-Equipped Fryers cont
instructions provided with the filtration equipment
B. When using a solid shortening, first melt it in a suitable container, or cut it into small pieces and pack it below the heat tubes, between the tubes and on top of the tubes, leaving no air spaces around the tubes. Do not disturb or bend the sensing bulbs
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
THIS PAGE INTENTIONALLY LEFT BLANK
5.1.1 Daily
5.1 General
5.1.2 Weekly
result
See filtration manual for filtration maintenance procedures
CHAPTER 5 PREVENTATIVE MAINTENANCE 5.1.3 Periodic/ Annual
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE
5.1.4 Stainless Steel Care DANGER
6.1 General
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
6.2 Pilot Burner Malfunction
DANGER
6.3 Main Burner Malfunctions
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
6.4 Wiring Diagrams
6.5 Recommended Spare Parts
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
Dean, 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana
SERVICE HOTLINE
Shipping Address 8700 Line Avenue, Shreveport, Louisiana
FAX Parts