24-Hour Service Hotline
Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
8195895
Page
other cooking appliance DANGER
the fryer under a hood. Questions? Call the Dean Service Hotline at
DANGER
from slips or contact with the hot oil DANGER
Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
TABLE OF CONTENTS
TABLE OF CONTENTS CONT
Dean Millivolt Gas Fryers Non-CE Installation & Operation Manual
Page #
THIS PAGE INTENTIONALLY LEFT BLANK
1.2 Ordering Parts
1.3 Service Information
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
1.1 After Purchase
Example of a CAUTION box
1.4 Safety Information
1.5 Service Personnel
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 1 INTRODUCTION
1.5.1 Definitions cont
B. Qualified Installation Personnel
C. Qualified Service Personnel
THIS PAGE INTENTIONALLY LEFT BLANK
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
2.1 Receiving and Unpacking Equipment
2.2 General
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
2.2 General cont
2.3 Principles of Operation
2.4 Rating Plate
DANGER
2.5 Pre-Installation
this chapter
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
2.5 Pre-Installation cont
2.6 Equipment Installed at High Altitudes
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
DANGER
2.7 Air Supply and Ventilation
2.7 Air Supply and Ventilation cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 2 IMPORTANT INFORMATION
THIS PAGE INTENTIONALLY LEFT BLANK
movement to avoid damage and possible bodily injury DANGER
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.1 Installing the Fryer
3.2 Leg and Caster Installation
3.2 Leg and Caster Installation cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.3 Leveling the Fryer
E. Installing Optional Swivel Casters
before installing the casters
3.3 Leveling the Fryer cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
DANGER
3.4 Gas Connections
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.3 Leveling the Fryer cont
Recommended Gas Supply Line Sizes
3.4 Gas Connections cont
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
Supply Line Specifications
Rigid Connections
damage to the fryer’s gas piping and gas valves
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.4 Gas Connections cont
E. Flexible Couplings, Connectors and Casters
new connections
Personal injury may result
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.5 Adjustments/Adaptation To Different Gases
GAS SUPPLY FOR WHICH IT IS NOT CONFIGURED
defined in Section 1.5 of this manual
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.6 Gas Inputs
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.7 Gas Conversion Procedures
Natural Gas to Propane Kit
3.7 Gas Conversion Procedures cont
3.8 Gas Conversion Components
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
3.9 Electrical Connections
DEAN MILLIVOLT GAS FRYERS NON-CE CHAPTER 3 INSTALLATION INSTRUCTIONS
DANGER
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
4.1 Initial Start-up
DANGER
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
4.1.1 Pilot Lighting Procedures, Standing Pilot Only
DANGER
4.2 Boil-Out Procedure
4.2.1 Thermostat-Equipped Fryers
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
4.2.1 Thermostat-Equipped Fryers cont
contents of the frypot
will damage the heating tubes and frypot, and void the warranty
4.3 Final Preparation
instructions provided with the filtration equipment
B. When using a solid shortening, first melt it in a suitable container, or cut it into small pieces and pack it below the heat tubes, between the tubes and on top of the tubes, leaving no air spaces around the tubes. Do not disturb or bend the sensing bulbs
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 4 FRYER OPERATIONS
THIS PAGE INTENTIONALLY LEFT BLANK
result
5.1 General
5.1.1 Daily
5.1.2 Weekly
5.1.4 Stainless Steel Care DANGER
CHAPTER 5 PREVENTATIVE MAINTENANCE 5.1.3 Periodic/ Annual
See filtration manual for filtration maintenance procedures
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE
DANGER
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
6.1 General
6.2 Pilot Burner Malfunction
6.3 Main Burner Malfunctions
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
6.4 Wiring Diagrams
6.5 Recommended Spare Parts
DEAN MILLIVOLT SERIES GAS FRYERS NON-CE CHAPTER 6 TROUBLESHOOTING
FAX Parts
SERVICE HOTLINE
Dean, 8700 Line Avenue, PO Box 51000, Shreveport, Louisiana
Shipping Address 8700 Line Avenue, Shreveport, Louisiana