Invacare HMV Highly 300, HMV Highly 400

SECTION 12—BATTERIES

Part No. 1118395 57 300 and 400

5. Slide terminal cap(s) UP on the battery cable(s).

6. Disconnect battery cable(s) from battery(ies) terminal(s)/post(s):

A. POSITIVE (+) RED battery cable from the POSITIVE (+) battery terminal/post.

B. NEGATIVE (-) BLACK battery cable from NEGATIVE (-) battery terminal/post.

FIGURE 12.5 - CONNECTING/DISCONNECTING THE BATTERY CABLES ON

THE 400

NOTE: Only battery cable and terminal cap shown. Both caps install in the same manner.

NOTE: Do not remove fuse or mounting hardware from the POSITIVE (+) RED battery cable/

mounting screw.

BLACK Battery

Cable

DETAIL “ A” - TERMIN AL CAPS TIE

WRAPS

Battery Handle

Battery Terminal

Caps

U1 Battery

Tie Wraps

POSITIVE (+)

Terminal Cap

U1 Battery

NEGATIVE (-)

Terminal Cap

TO BLACK BATTERY

CONNECTOR

RED Battery Cable

POSITIVE (+) Battery

Terminal with Bracket

NEGATIVE (-)

Battery

Terminal

Locknut

Contents

Main WARNING Page Page Page REGISTER YOUR PRODUCT PRODUCT REGISTRATION FORM Page SPECIAL NOTES NOTICE TYPICAL PRODUCT PARAMETERS TYPICAL PRODUCT PARAMETERS 300 400 LABEL LOCATIONS ON 300 LABEL LOCATIONS 300 and 400 12 Part No. 1118395 ON 400 Front Frame Assembly !WARNING Pinch Point. !WARNING SECTION 1GENERAL GUIDELINES REPAIR OR SERVICE INFORMATION OPERATION INFORMATION Page TIRE PRESSURE ELECTRICAL GROUNDING INSTRUCTIONS BATTERIES RAIN TEST WEIGHT TRAINING Page SECTION 2EMI INFORMATION Page SECTION 3SAFETY/HANDLING OF POWERED SCOOTERS STABILITY AND BALANCE PERCENTAGE OF WEIGHT DISTRIBUTION STAIRWAYS ESCALATORS SECTION 4SAFETY INSPECTION SAFETY INSPECTION CHECKLISTS INSPECT/ADJUST INITIALLY INSPECT/ADJUST WEEKLY INSPECT/ADJUST MONTHLY INSPECT/ADJUST EVERY SIX (6) MONTHS INSPECT/ADJUST PERIODICALLY SECTION 5MAINTENANCE AND TROUBLESHOOTING SUGGESTED MAINTENANCE PROCEDURES LUBRICATION POINTS SECTION 5MAINTENANCE AND TROUBLESHOOTING FIGURE 5.1 - LUBRICATION POINTS TROUBLESHOOTING SYMPTOM PROBABLE CAUSE SOLUTION SECTION 6OPERATION OF THE POWERED SCOOTER CONTROL PANEL SECTION 6OPERATION OF THE POWERED SCOOTER SCOOTER NOTES Page OPERATING THE SCOOTER BRAKE RELEASE LEVER RESETTING THE CIRCUIT BREAKER REPLACING THE FUSE SECTION 7SEAT REMOVING/INSTALLING THE SEAT REMOVING/INSTALLING THE SEAT POST ADJUSTING SEAT HEIGHT ADJUSTING SEAT DEPTH 90 SEAT SWIVEL ADJUSTMENT REMOVING/INSTALLING SEAT POSITIONING STRAP Page SECTION 8ARMS REMOVING/INSTALLING/ADJUSTING ARMS REMOVING/INSTALLING ADJUSTING ARM WIDTH ADJUSTING ARM ANGLE ADJUSTING ARM HEIGHT REPLACING ARMREST PADS SECTION 9TILLER ADJUSTMENT ADJUSTING THE TILLER ANGLE WARNING SECTION 10REAR SHROUD REMOVING/INSTALLING THE REAR SHROUD SECTION 11WHEELS AND CASTERS REMOVING/INSTALLING THE DRIVE WHEELS SECTION 11WHEELS AND CASTERS FIGURE 11.1 - REMOVING/INSTALLING THE DRIVE WHEELS REMOVING/INSTALLING THE FRONT WHEEL REMOVING/INSTALLING THE CASTER ASSEMBLIES SECTION 12BATTERIES RECOMMENDED BATTERY TYPE REMOVING/INSTALLING THE BATTERIES ON 300 Page Page REMOVING/INSTALLING THE BATTERIES ON 400 SECTION 12BATTERIES NOTE: Seat and Rear Shroud not shown for clarity. FIGURE 12.3 - REMOVING/INSTALLING THE BATTERIES ON 400 CONNECTING/DISCONNECTING THE BATTERY CABLES ON THE 400 CONNECTING DISCONNECTING Page CHARGING THE BATTERIES ON-BOARD BATTERY CHARGER BATTERY CHARGER OPERATION - CHARGER INDICATOR LIGHT ON TILLER SECTION 13TRANSPORTING TRANSPORTING THE SCOOTER Page Page SECTION 13TRANSPORTING FIGURE 13.2 - TRANSPORTING THE SCOOTER - 400 SECTION 14SCOOTER ACCESSORIES REMOVING/INSTALLING THE FRONT BASKET INSTALLING/REMOVING THE CRUTCH/CANE HOLDER INSTALLING/REMOVING THE SAFETY FLAG INSTALLING/REMOVING/USING THE WALKER HOLDER INSTALLATION WARNINGS INSTALLING/REMOVING THE WALKER HOLDER USING THE WALKER HOLDER INSTALLING/REMOVING THE REAR MOUNTED BASKET Page Page LIMITED WARRANTY LIMITED WARRANTY