REMOVING/INSTALLING the Drive Wheels | Invacare HMV Highly 300

SECTION 11—WHEELS AND CASTERS

DETAIL “A” - 300

Keystock

WARNING:

PINCH POINT

	Cutout
Drive	Washer	Scooter Frame
Drive		Scooter Frame
Shaft	Hex Nut
	Hex Nut
		Drive Wheel
		DETAIL “B” - 400
	Swingarm

Scooter Frame

Keystock

Washer

Hex Nut

Drive Shaft

Drive Wheel

FIGURE 11.1 - REMOVING/INSTALLING THE DRIVE WHEELS

300 and 400

46

Part No. 1118395

Image 46

Invacare HMV Highly 300, HMV Highly 400 manual REMOVING/INSTALLING the Drive Wheels

Contents

HMVHighly Maneuverable Vehicle 300 Table of Contents Arms Tiller AdjustmentSeat Rear Shroud Batteries Scooter AccessoriesTransporting Register Your Product Register Your Product Product Registration Form Fold here Cut Along Line TIE-DOWN Restraints and Seat Restraints Special NotesSeat Positioning Strap Typical Product Parameters 300 400 Label Locations Front Frame Assembly General Guidelines Repair or Service InformationOperation Information General Guidelines Tire Pressure Electrical Rain Test Weight TrainingBatteries Grounding Instructions Weight Limitation EMI Information EMI Information EMI Information Percentage of Weight Distribution SAFETY/HANDLING of Powered ScootersStability and Balance Stairways Escalators Safety Inspection Checklists Safety InspectionINSPECT/ADJUST Initially INSPECT/ADJUST Monthly INSPECT/ADJUST WeeklyINSPECT/ADJUST Every SIX 6 Months INSPECT/ADJUST Periodically Suggested Maintenance Procedures Maintenance and TroubleshootingLubrication Points Troubleshooting Symptom Probable Cause Solution Operation of the Powered Scooter Control Panel Number Fault Impact on Control Panel Operation of the Powered Scooter Number Fault Impact on Control Panel Horn and Throttle Control Lever Operating the Scooter Brake Release Lever Resetting the Circuit Breaker Brake Release Lever Replacing the Fuse Replacing the Fuse Seat REMOVING/INSTALLING the SeatInstalling Removing REMOVING/INSTALLING the Seat Post REMOVING/INSTALLING the Seat Post Adjusting Seat Height Adjusting Seat Depth Seat Swivel Adjustment Adjusting Seat Depth REMOVING/INSTALLING Seat Positioning Strap 90 Seat Swivel Adjustment REMOVING/INSTALLING Seat Positioning Strap Adjusting ARM Width REMOVING/INSTALLING/ADJUSTING ArmsREMOVING/INSTALLING Arms Adjusting ARM Angle Adjusting ARM Height Adjusting ARM Height Replacing Armrest Pads Tiller Adjustment Adjusting the Tiller Angle REMOVING/INSTALLING the Rear Shroud Rear Shroud REMOVING/INSTALLING the Drive Wheels Wheels and Casters REMOVING/INSTALLING the Drive Wheels REMOVING/INSTALLING the Front Wheel REMOVING/INSTALLING the Front Wheel REMOVING/INSTALLING the Caster Assemblies REMOVING/INSTALLING the Caster Assemblies Batteries Recommended Battery Type REMOVING/INSTALLING the Batteries on Removing REMOVING/INSTALLING the Batteries on REMOVING/INSTALLING the Batteries on Built-in Lifting Straps CONNECTING/DISCONNECTING the Battery Cables on Connecting Disconnecting CONNECTING/DISCONNECTING the Battery Cables on ON-BOARD Battery Charger Charging the Batteries Battery Charger Operation Charger Indicator Light on Tiller Charging Indicator Status Disassembling TransportingTransporting the Scooter Assembling 400 Transporting Right Scooter Accessories REMOVING/INSTALLING the Front Basket INSTALLING/REMOVING the CRUTCH/CANE Holder INSTALLING/REMOVING the CRUTCH/CANE Holder INSTALLING/REMOVING/USING the Walker Holder INSTALLING/REMOVING the Safety FlagInstallation Warnings INSTALLING/REMOVING the Walker Holder Using the Walker Holder INSTALLING/REMOVING the Rear Mounted Basket INSTALLING/REMOVING the Rear Mounted Basket 300 300 Limited Warranty Limited Warranty USA