SECTION
FIGURE 5.1 - LUBRICATION POINTS
TROUBLESHOOTING
SYMPTOM | PROBABLE CAUSE | SOLUTION |
|
|
|
LIMITED DRIVING | Battery not charged long enough. | Charge batteries overnight or ensure eight |
DISTANCE. |
| (8) hours of charge between use. |
| Batteries weak, won’t hold | Replace batteries. Refer to Removing/ |
| charge. | Installing the Batteries on 300 on page 50 |
|
| OR Removing/Installing the Batteries on |
|
| 400 on page 53. |
|
|
|
BATTERIES NOT | Charger not working. | Replace charger. Contact Dealer or a quali- |
CHARGING. |
| fied technician. |
| Battery connections loose. | Check all connections. Secure connections. |
|
| Refer to Removing/Installing the Batteries |
|
| on 300 on page 50 OR Removing/Installing |
|
| the Batteries on 400 on page 53. |
|
| Switch another wall outlet. |
| No current at wall outlet. | Replace charger or internal repairs |
| Bad connection on charger, | required. Contact Dealer or a qualified |
| charger cable, plug or internal | technician. |
| wiring problem. |
|
|
|
|
BATTERIES DRAW | Battery failure. | Replace batteries. Refer to Removing/ |
EXCESSIVE CURRENT |
| Installing the Batteries on 300 on page 50 |
WHEN CHARGING. |
| OR Removing/Installing the Batteries on |
|
| 400 on page 53. |
|
|
|
BATTERY INDICA- | Charger not working. | Have charger checked. Service or replace |
TOR SHOWS THE |
| the charger. Contact Dealer or a qualified |
CHARGE LEVEL IS |
| technician. |
LOW - TOO SOON | Weak batteries. | Replace batteries. Refer to Removing/ |
AFTER BEING |
| Installing the Batteries on 300 on page 50 |
RECHARGED. |
| OR Removing/Installing the Batteries on |
|
| 400 on page 53. |
|
|
|
SCOOTER WILL NOT | Brake release lever disengaged. | Engage brake release lever. Refer to Brake |
DRIVE. |
| Release Lever on page 31. |
| Batteries require charging. | Charge batteries. Refer to Charging the Bat- |
|
| teries on page 58. |
| Key not fully plugged in. | Ensure key is inserted fully into keyswitch. |
| Charger plugged in. | Unplug charger from scooter. |
| Circuit breaker tripped. | Reset breaker. Refer to Resetting the Cir- |
|
| cuit Breaker on page 32. If breaker trips |
|
| again, it may indicate need for internal |
|
| repairs. Contact Dealer or a qualified tech- |
|
| nician. |
| Soft stop engaged. If key is turned | With key in the off position, wait for 30 sec- |
| off while driving, the scooter | onds and turn key to the on position. |
| holds power for 1.5 seconds |
|
| slowly decelerating to a stop. |
|
|
|
|
300 and 400 | 26 | Part No. 1118395 |
