Manuals / Nortec / Household Appliance / Humidifier

Nortec NHPC, NHTC 10-30, SAM-eHeader cont, Adjustable Mounting Frame for SAM-e, SAM-eTube Matrix

Models: NHPC NHTC

1 125

Download 125 pages 49.33 Kb

Page 114

Table 5. SAM-e Header (cont)

Part No.	Description	Qty

1506803	12" CENTERS, 108" (274.3 cm) WIDE
	9 Steam tubes

1506804	12" CENTERS, 120" (304.8 cm) WIDE
	10 Steam tubes

1506805	12" CENTERS, 132" (335.3 cm) WIDE
	11 Steam tubes

1506806	12" CENTERS, 144" (365.8 cm) WIDE
	12 Steam tubes

– – –	12" CENTERS, 144+" (365.8+ cm) WIDE
	Consult factory

Table 6. Adjustable Mounting Frame for SAM-e

Part No.	Description	Qty

1504697	MOUNTING FRAME
	SAM-e 9" to 15"

1503469	MOUNTING FRAME
	SAM-e 16" to 27"

1503470	MOUNTING FRAME
	SAM-e 28" to 51"

1503471	MOUNTING FRAME
	SAM-e 52" to 99"

Table 7. SAM-e Tube Matrix

Part No.	Description	Qty

1503388	TYPE A, 18" (45.7 cm) WIDE
	15 lbs/hr (7 kg/hr)

1503389	TYPE A, 24" (61.0 cm) WIDE
	15 lbs/hr (7 kg/hr)

1503390	TYPE A, 30" (76.2 cm) WIDE
	15 lbs/hr (7 kg/hr)

1503391	TYPE A, 36" (91.4 cm) WIDE
	15 lbs/hr (7 kg/hr)

1503392	TYPE A, 42" (106.7 cm) WIDE
	15 lbs/hr (7 kg/hr)

1506393	TYPE A, 48" (121.9 cm) WIDE
	15 lbs/hr (7 kg/hr)

1503394	TYPE A, 54" (137.2 cm) WIDE
	15 lbs/hr (7 kg/hr)

1503395	TYPE A, 60" (152.4 cm) WIDE
	15 lbs/hr (7 kg/hr)

10-30

Page 106 2008-10-01

Image 114

Nortec NHPC, NHTC manual 10-30, SAM-eHeader cont, Adjustable Mounting Frame for SAM-e, SAM-eTube Matrix, Page 106

Contents

Engineering Manual NH SeriesTMNHTC / NHPC ELECTRODE STEAM HUMIDIFIER 2538144-BLIABILITY NOTICE SPECIFICATION LABEL LOCATIONPROPRIETARY NOTICE COPYRIGHT NOTICE10-10HUMIDITY, STEAM ABSORPTION AND DISTRIBUTION TABLE OF CONTENTS10-00ELECTRODE STEAM ENGINEERING Subject10-30SUBMITTALS 10-20SPECIFICATIONSWARRANTY Subject10-10HUMIDITY, STEAM ABSORPTION AND DISTRIBUTION LIST OF FIGURES10-00ELECTRODE STEAM ENGINEERING FigureFigure 10-30SUBMITTALSFigure 2008-10-0110-10HUMIDITY, STEAM ABSORPTION AND DISTRIBUTION LIST OF TABLES10-00ELECTRODE STEAM ENGINEERING 10-30SUBMITTALSTable 13. Modulating Demand Signal By Others Single Channel. . . . . . . . . . . . . . . . . . . 2008-10-0110-00 INTRODUCTION 10-00Page 10-00 Figure 1. NHTCPage 2 1. INTRODUCTION 10-00Page 3 10-00 Page 4Figure 3. Conductivity 10-00Figure 2. Optimum Boiling Time Page 5C.DRAIN CYCLE AND CYLINDER LIFE B.NH CAPACITY ADJUSTMENT10-00 1Water Type Used Potable or Softened10-00 1.Fill to A trigger use all places below10-00 Figure 5. Capacity Setting & Cylinder LifeFigure 6. Output vs Service Life Page 83.PRE-INSTALLATIONEQUIPMENT VERIFICATION 10-00A.GENERAL Figure 6. Typical NHRS Installation Sheet 1 of 10-00Page 10 Figure 7. Typical NHRS Installation Sheet 2 of 10-00Page 11 10-10 HUMIDITY STEAM ABSORPTION AND DISTRIBUTION 10-10Page 12 C.TEMPERATURE AND HUMIDITY REQUIRED HUMIDITY, STEAM ABSORPTION AND DISTRIBUTION1. HUMIDITY D.TEMPERATURE AND HUMIDITY AVAILABLETable 2. Load Calculation Summary Sheet Outdoor temperature10-10 Page 14E.INCOMING AIR VOLUME 10-10Page 15 Page 16 10-10Table 4. Design Outdoor Conditions JANUARYPage 17 10-10Table 4. Design Outdoor Conditions cont JANUARYPage 18 10-10Table 4. Design Outdoor Conditions cont JANUARY10-10 Page 1910-10 Page 2010-10 Page 2110-10 Table 6. Regain of Hygroscopic MaterialsPage 22 10-10 Page 2310-10 Page 2410-10 Page 25Page 26 Temperature10-10 Product and/or ProcessFigure 2. Psychrometric Chart 10-10Page 27 A.VARIABLES THAT AFFECT ABSORPTION DISTANCES 2.STEAM ABSORPTION AND DISTRIBUTION10-10 Page 2810-10 Figure 3. Steam Distributor LocationPage 2The following are two examples: Example 10-10B.CALCULATING THE DOWN STREAM HUMIDITY LEVEL Page 30Figure 4. Condensate Drain Pan 10-10C.CONTROL OF DUCT OR PLENUM SATURATION Page 31A.STEAM RUNS 3.STEAM RUNS AND CONDENSATE RETURNS10-10 Figure 5. Proper Slope10-10 Table 11. Steam Line MaterialPage 33 Page 10-10B.CONDENSATE RETURN Unit SizeIn Steam Line 10-10Figure 8. Condensate Tee At Any Low Point Figure 7. Steam Line Connection10-10 Page 3610-10 4.STEAM DISTRIBUTORS ASD, BSD, CSDB.DISTRIBUTOR CHARACTERISTICS A.STEAM DISTRIBUTORSD.MULTIPLE DISTRIBUTOR APPLICATIONS 10-10C.DISTRIBUTOR LOCATIONS AND MOUNTING Page 38Figure 13. Humidification Distance Nomogram 10-10Figure 12. Cutting Duct For Mounting Page 39Figure 14. Best Location for Multiple Steam 10-10F.DISTRIBUTOR ABSORPTION DISTANCE Distributors in AHUG.TYPICAL APPLICATIONS H.DISTRIBUTOR DIMENSIONS10-10 Figure 15. Roof Top Units 2-20Tons –A.GENERAL 5.SHORT ABSORPTION MANIFOLD SAM-e10-10 Figure 17. SAM-eTubes10-10 B. DETERMINING THE STEAM ABSORPTION DISTANCEPage 43 C.STATIC AIR PRESSURE 10-10NOTES Table 15. Air Pressure Loss in AHU/DuctFigure 20. Absorption Distance – 6 Centers 10-10Figure 19. Absorption Distance – 3 Centers Figure 21. Absorption Distance – 9 CentersTable F.SAM-eDIMENSIONS10-10 Condensate LossFigure 24. SAM-eTubes 10-10Figure 23. SAM-eHeader Figure 25. Steam Inlet1Atmospheric Steam NH, GS, SE I.SAM-eSTEAM INLET CONFIGURATION SELECTION10-10 J.MINI SAM-eTable 19. Mini SAM-eHeaders – 10-10Table 18. Mini SAM-eHeaders – Table 20. Mini SAM-eTubes10-10 Page 50ABOVE THE FLOOR A.BLOWER PACKS 6. BLOWER PACKS BOBP, RMBP10-10 Figure 27. NH Series Humidifier WithNH Series Model 10-10Page 52 Minimum Number OfA.GENERAL 7.CONTROLS10-10 THIS FUNCTION B.ON/OFF CONTROLS10-10 D.OUTDOOR TEMPERATURE SETBACKFigure 29. Set Point Versus Outdoor Temperature E.TRANSDUCER SENSORSG.NORTEC ONLINE 10-10F.POSITIONING CONTROLS AND SENSORS Page 5510-10 Figure 30. NORTEC OnLine MonitoringPage 56 10-10 H. NORTEC LINKSPage 57 1See dimensions in Chapter I.TYPICAL INSTALLATION LAYOUT FOR NHTC/NHPCJ.NORTEC CONTROLLER DIMENSIONS 10-1010-10 NORTEC ONLINE CONFIGURATION FORMFigure 31. NORTEC Online Configuration Form G FOR YOUR INFORMATIONPlease complete the information below NORTEC LINKS FORM10-10 Figure 32. NORTEC Links FormModulating Wall Mounted Space Controller 10-10Modulating Wall Mounted Space Controller Page 6110-10 Page 6210-20 SPECIFICATIONS 10-20Page 63 4Warranty SPECIFICATIONS1.HUMIDIFIERS 10-2010-20 Page 6510-20 2Humidifier Controls NHTC and NHTC OutdoorPage 10-20 Page 6710-20 Page 6810-20 4Humidifier Dispersion OptionsPage 69 10-20 C. EXECUTION 1ExaminationPage 70 10-20 2Installation4Testing 3Commissioning10-20 Page 7210-30 SUBMITTALS 10-30Page 73 A.INTRODUCTION 1. SUBMITTAL DESCRIPTIONS10-30 B.NH UNITF. CONTROLS 10-302Built-OnBlower Pack NHTC and NHPC only Page 7510-30 Page 7610-30 Figure 1. Low Voltage Control Terminal StripPage 77 Figure 2. Primary Line Voltage Wiring to Unit 10-30Page 10-30 Figure 3. Physical Data – NHTC/NHPCPage 79 10-30 Figure 4. Physical Data – NHTC/NHPCPage 80 10-30 Figure 5. Physical Data – NHTC/NHPCPage 81 10-30 Unit ModelDistributor Dimensions – in mm10-30 Minimum DuctDistributor Dimensions – in mm10-30 ModelDuct Height 10-30Duct Width D Tube Height10-30 Duct Width10-30 Page 8710-30 Page 8810-30 Page 8910-30 Page 90Figure 15. Outside Duct Mounting Cover Plates Figure 14. Vertical Duct Installation10-30 Page 91Figure 16. Atmospheric SAM-eAdapter Dimensions 10-30Page 92 10-30 Page 9310-30 Page 9410-30 Page 9510-30 Page 96Wall Digital Humidistat Dimensions 10-30Duct Sensor Dimensions 10-30B.INSTALLATION COMPONENT SELECTION 10-302.SUBMITTALS A.INTRODUCTIONTable 3. Steam Distributors Table 2. Common Accessories Universal10-30 Page 100Table 3. Steam Distributors cont Table 4. Steam Distributor Accessories10-30 Page 10110-30 Table 4. Steam Distributor Accessories contOther Accessories Page 10210-30 Table 5. SAM-eHeaderPage 103 10-30 Table 5. SAM-eHeader contPage 104 10-30 Table 5. SAM-eHeader contPage 105 Table 5. SAM-eHeader cont Table 6. Adjustable Mounting Frame for SAM-e10-30 Table 7. SAM-eTube Matrix10-30 Table 7. SAM-eTube Matrix contPage 107 10-30 Table 7. SAM-eTube Matrix contPage 108 10-30 Table 7. SAM-eTube Matrix contPage 109 Table 7. SAM-eTube Matrix cont Table 8. SAM-eInlet and Adapter Configurations10-30 Page 110Table 10. Built-OnBlower Pack 10-30Table 9. Remote Blower Pack Page 111Table 12. Modulating Control By NORTEC 10-30Table 11. Controls – ON/OFF Page 11210-30 Page 113Table 16. NORTEC OnLine Options NHTC only Table 18. NH Series Fusing Options10-30 Table 17. NORTEC Links Options NHTC onlyControl Information 10-30C. SCHEDULE Humidifier Information Distributor InformationWARRANTY 2740 Fenton Road Cylinder Replacement Date MM/DD/YYYY826 Proctor Avenue Ogdensburg, NY