Quadra-Fire CASTINS-CWL, 810-03201 Table Of Contents, Castile Pellet Insert Safety Alert Key

R

Castile Pellet Insert

Safety Alert Key:

•DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.

•WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.

•CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

•NOTICE: Indicates practices which may cause damage to the fi replace or to property.

TABLE OF CONTENTS

Section 1: Listing and Code Approvals

A.	Appliance Certifi cations	4
B.	Mobile Home Approved	4
C.	Glass Specifi cations	4
D.	Electrical Rating	4
E.	BTU & Effi ciency Specifi cations	4
Section 2: Getting Started
A.	Design, Installation & Location
	Considerations	5
B.	Locating Your Appliance & Chimney ..	6
C.	Draft	6
D.	Negative Pressure	6
E.	Fire Safety	7
F.	Tools & Supplies Needed	7
G.	Inspect Appliance, Components
	and Pre-Use Check List	7
Section 3: Dimensions & Clearances
A.	Appliance Dimensions	8
B.	Clearances to Combustibles
	As A Built-In, UL and ULC	9
C.	Clearances to Combustibles,
	Masonry & Zero Clearance	10
D.	Floor Protection	10
E.	Minimum Opening for Factory-
	Built Fireplace	10
F.	Removing Floor of Factory-Built
	Fireplace	11
G. Prefabricated Metal Chimney		12
H.	Altering Factory-Built Fireplace	12
Section 4: Vent Information
A.	Chimney & Exhaust Connections	13
B.	Venting Termination Requirements ....	13
C.	Equivalent Feet of Pipe	14
D.	Pipe Selection Chart	14
Section 5: Venting Systems
A. Full Reline with Outside Air-Horizontal 15
B. Full Reline with Outside Air-Vertical....		16
Section 6: Mobile Home		17

Section 7: Appliance Set-Up
A. Reversible Top & Rear Flue Adapter ....		18
B.	Leveling System	18
C.	Outside Air Kit	19
D.	Zero Clearance Trim Support	19-20
E.	Panel Set & Cast Trim	21
F.	Panel & Trim Set Econo	21
G.	Log Set Placement	22
H.	Thermostat Installation	23
Section 8: Operating Instructions
A. Fuel Size, Material & Storage		24
B.	General Operation Information	25
C.	Before Your First Fire	25
D.	Starting Your First Fire	25
E.	Fire Characteristics	25
F.	Feed Rate Adjustment	26
G.	Ignition Cycles	26
H.	Frequently Asked Questions	27
Section 9: Troubleshooting		28-30
Section 10: Maintaining & Servicing Appliance
A.	Proper Shutdown Procedures	31
B. Quick Reference Maintenance Chart..		31
C. General Maintenance & Cleaning		32-35
D. High Ash Content Maintenance		35
E.	Igniter Replacement	36
F.	Glass Replacement	36
G. Baffl e & Brick Removal		37-38
Section 12: Reference Material
A.	Component Functions	39-40
B.	Component Locations	41
C.	Exploded Drawing	42
D. Service Parts & Accessories		43-47
E. Service & Maintenance Log		48-49
F.	Warranty Policy	50-51
G.	Contact Information	52

August 20, 2009 250-7251G Page 3