U32 Sunrise Gas Insert | Regency U32S-LP5 instruction

Image 1

Regency U32S-LP5, U32S-NG5 installation manual U32 Sunrise Gas Insert, Owners, Installation Manual, 918-788

Contents

U32 Sunrise Gas Insert Installation ManualOwners 918-788 TO THE NEW OWNER SAFETY LABEL TABLE OF CONTENTSMAINTENANCE PARTS LIST SAFETY LABEL MA Code - CO Detector REQUIREMENTSfor the State of Massachusetts only 5.08 Modifications to NFPA-54,Chapter U32S-5FPI Direct Vent Gas Insert UNIT DIMENSIONS FOR YOUR SAFETY INSTALLATIONSPECIFICATIONS GAS PRESSURE TESTING INSTALLATION CHECKLIST INSTALLATIONMINIMUM FIREPLACE DIMENSIONS MANUFACTURED MOBILE HOME ADDITIONAL REQUIREMENTS GAS CONNECTION INSTALLATIONVENTING COMBUSTIBLE MANTEL FLUE LINER INSTALLATION INSTALLATIONGAS PIPE PRESSURE TESTING GAS INSERT AERATION SYSTEM U32S-5using SIT 820 NOVA Gas Valve INSTALLATIONCONVERSION KIT # 434-969FROM NG TO LP IF IN DOUBT DO NOT DO THIS CONVERSION Installer Notice INSTALLATIONDo not overtighten the screw. Recommended to grip the wrench by the short side Installation of the DC Sparker INSTALLATIONIgnitor Wire Piezo Ignitor Ground wire from kit OPTIONAL REMOTE CONTROL INSTALLATIONto the 120V wires Thermostat Wire Table remote control the 120V wires WIRING DIAGRAMS INSTALLATIONCAUTION Label all wires prior to disconnection when servicing INSTALLATION INSTALLATION ON BURNER INSTALLATIONGLASS CRYSTAL OR OPTIONAL CERAMIC STONES Minimum Air shutter Opening Diagram Diagram 1a Diagram 1b Diagram INSTALLATIONSTANDARD FLUSH DOOR FACEPLATE AND DOOR FRAME INSTALLATION INSTALLATIONKit# 425-914Contents List Door Frame Completed Faceplate & Door Frame Installation INSTALLATION8Lower the door frame gently into place 10Slide unit into ﬁnal position OPTIONAL HEARTH TRIM INSTALLATION INSTALLATION2 Hearth Trim Installation 4 Hearth Trim Installation LIGHTING PROCEDURE OPERATING INSTRUCTIONSSHUTDOWN PROCEDURE OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS MAINTENANCE INSTRUCTIONSCOPY OF LIGHTING INSTRUCTION PLATE DO NOT REMOVE THIS INSTRUCTION PLATE GENERAL VENT MAINTENANCE MAINTENANCEDOOR GLASS GLASS GASKET FAN MAINTENANCE MAINTENANCEFAN REMOVAL Burner Fan access plate MAINTENANCEPilot assembly wires Base Cover REPLACING THE FAN MAINTENANCE VALVE ASSEMBLY REPLACEMENT MAINTENANCEON/OFF Wires Burner 11Slightly lift out valve tray MAINTENANCE12 Disconnect the inlet gas line U32S-5FPI Direct Vent Gas Insert MAIN ASSEMBLY PARTS LISTDescription BURNER ASSEMBLY PARTS LISTDescription 4 10 11 9 13 1425-512Door Bottom Assembly 2425-513Frame Inside PARTS LISTFACEPLATE AND DOORFRAME 3425-514Faceplate Outside 4425-942Hearth Trim U32S-5FPI Direct Vent Gas Insert U32S-5FPI Direct Vent Gas Insert The Warranty Limited Lifetime WARRANTYConditions Exclusions See the inside back cover for details

Regency U32S-LP5 installation manual U32 Sunrise Gas Insert, Owners, Installation Manual, 918-788

Models: U32S-NG5 U32S-LP5