To The New Owner | Regency U32S-NG5, U32S-LP5 specification

Image 2

Regency U32S-NG5, U32S-LP5 installation manual To The New Owner

Contents

Owners Installation ManualU32 Sunrise Gas Insert 918-788 TO THE NEW OWNER MAINTENANCE TABLE OF CONTENTSSAFETY LABEL PARTS LIST SAFETY LABEL for the State of Massachusetts only REQUIREMENTSMA Code - CO Detector 5.08 Modifications to NFPA-54,Chapter UNIT DIMENSIONS U32S-5FPI Direct Vent Gas Insert SPECIFICATIONS INSTALLATIONFOR YOUR SAFETY GAS PRESSURE TESTING MINIMUM FIREPLACE DIMENSIONS INSTALLATIONINSTALLATION CHECKLIST MANUFACTURED MOBILE HOME ADDITIONAL REQUIREMENTS VENTING INSTALLATIONGAS CONNECTION COMBUSTIBLE MANTEL GAS PIPE PRESSURE TESTING INSTALLATIONFLUE LINER INSTALLATION GAS INSERT AERATION SYSTEM CONVERSION KIT # 434-969FROM NG TO LP INSTALLATIONU32S-5using SIT 820 NOVA Gas Valve IF IN DOUBT DO NOT DO THIS CONVERSION Do not overtighten the screw. Recommended to grip INSTALLATIONInstaller Notice the wrench by the short side Ignitor Wire Piezo Ignitor INSTALLATIONInstallation of the DC Sparker Ground wire from kit to the 120V wires Thermostat Wire Table INSTALLATIONOPTIONAL REMOTE CONTROL remote control the 120V wires CAUTION Label all wires prior INSTALLATIONWIRING DIAGRAMS to disconnection when servicing INSTALLATION GLASS CRYSTAL OR OPTIONAL CERAMIC STONES INSTALLATIONINSTALLATION ON BURNER Minimum Air shutter Opening STANDARD FLUSH DOOR INSTALLATIONDiagram Diagram 1a Diagram 1b Diagram Kit# 425-914Contents List INSTALLATIONFACEPLATE AND DOOR FRAME INSTALLATION Door Frame 8Lower the door frame gently into place INSTALLATIONCompleted Faceplate & Door Frame Installation 10Slide unit into ﬁnal position 2 Hearth Trim Installation INSTALLATIONOPTIONAL HEARTH TRIM INSTALLATION 4 Hearth Trim Installation SHUTDOWN PROCEDURE OPERATING INSTRUCTIONSLIGHTING PROCEDURE OPERATING INSTRUCTIONS COPY OF LIGHTING INSTRUCTION PLATE MAINTENANCE INSTRUCTIONSOPERATING INSTRUCTIONS DO NOT REMOVE THIS INSTRUCTION PLATE DOOR GLASS MAINTENANCEGENERAL VENT MAINTENANCE GLASS GASKET FAN REMOVAL MAINTENANCEFAN MAINTENANCE Burner Pilot assembly wires MAINTENANCEFan access plate Base Cover MAINTENANCE REPLACING THE FAN ON/OFF Wires MAINTENANCEVALVE ASSEMBLY REPLACEMENT Burner 12 Disconnect the inlet gas line MAINTENANCE11Slightly lift out valve tray U32S-5FPI Direct Vent Gas Insert Description PARTS LISTMAIN ASSEMBLY Description PARTS LISTBURNER ASSEMBLY 4 10 11 9 13 FACEPLATE AND DOORFRAME PARTS LIST1425-512Door Bottom Assembly 2425-513Frame Inside 3425-514Faceplate Outside 4425-942Hearth Trim U32S-5FPI Direct Vent Gas Insert U32S-5FPI Direct Vent Gas Insert Conditions WARRANTYThe Warranty Limited Lifetime Exclusions See the inside back cover for details