Installation | Regency U32S-NG5, U32S-LP5 instruction

INSTALLATION

For PROPANE Units and Units Equipped with DC Spark Boxes*

*For installation of the DC Spark Box refer to the LP Conversion instructions in this manual.

16	U32S-5 FPI Direct Vent Gas Insert

Page 16

Image 16

Regency U32S-NG5, U32S-LP5 installation manual Installation

Contents

Installation Manual U32 Sunrise Gas InsertOwners 918-788 TO THE NEW OWNER TABLE OF CONTENTS SAFETY LABELMAINTENANCE PARTS LIST SAFETY LABEL REQUIREMENTS MA Code - CO Detectorfor the State of Massachusetts only 5.08 Modifications to NFPA-54,Chapter UNIT DIMENSIONS U32S-5FPI Direct Vent Gas Insert INSTALLATION FOR YOUR SAFETYSPECIFICATIONS GAS PRESSURE TESTING INSTALLATION INSTALLATION CHECKLISTMINIMUM FIREPLACE DIMENSIONS MANUFACTURED MOBILE HOME ADDITIONAL REQUIREMENTS INSTALLATION GAS CONNECTIONVENTING COMBUSTIBLE MANTEL INSTALLATION FLUE LINER INSTALLATIONGAS PIPE PRESSURE TESTING GAS INSERT AERATION SYSTEM INSTALLATION U32S-5using SIT 820 NOVA Gas ValveCONVERSION KIT # 434-969FROM NG TO LP IF IN DOUBT DO NOT DO THIS CONVERSION INSTALLATION Installer NoticeDo not overtighten the screw. Recommended to grip the wrench by the short side INSTALLATION Installation of the DC SparkerIgnitor Wire Piezo Ignitor Ground wire from kit INSTALLATION OPTIONAL REMOTE CONTROLto the 120V wires Thermostat Wire Table remote control the 120V wires INSTALLATION WIRING DIAGRAMSCAUTION Label all wires prior to disconnection when servicing INSTALLATION INSTALLATION INSTALLATION ON BURNERGLASS CRYSTAL OR OPTIONAL CERAMIC STONES Minimum Air shutter Opening Diagram Diagram 1a Diagram 1b Diagram INSTALLATIONSTANDARD FLUSH DOOR INSTALLATION FACEPLATE AND DOOR FRAME INSTALLATIONKit# 425-914Contents List Door Frame INSTALLATION Completed Faceplate & Door Frame Installation8Lower the door frame gently into place 10Slide unit into ﬁnal position INSTALLATION OPTIONAL HEARTH TRIM INSTALLATION2 Hearth Trim Installation 4 Hearth Trim Installation OPERATING INSTRUCTIONS LIGHTING PROCEDURESHUTDOWN PROCEDURE OPERATING INSTRUCTIONS MAINTENANCE INSTRUCTIONS OPERATING INSTRUCTIONSCOPY OF LIGHTING INSTRUCTION PLATE DO NOT REMOVE THIS INSTRUCTION PLATE MAINTENANCE GENERAL VENT MAINTENANCEDOOR GLASS GLASS GASKET MAINTENANCE FAN MAINTENANCEFAN REMOVAL Burner MAINTENANCE Fan access platePilot assembly wires Base Cover MAINTENANCE REPLACING THE FAN MAINTENANCE VALVE ASSEMBLY REPLACEMENTON/OFF Wires Burner MAINTENANCE 11Slightly lift out valve tray12 Disconnect the inlet gas line U32S-5FPI Direct Vent Gas Insert MAIN ASSEMBLY PARTS LISTDescription PARTS LIST BURNER ASSEMBLYDescription 4 10 11 9 13 PARTS LIST 1425-512Door Bottom Assembly 2425-513Frame InsideFACEPLATE AND DOORFRAME 3425-514Faceplate Outside 4425-942Hearth Trim U32S-5FPI Direct Vent Gas Insert U32S-5FPI Direct Vent Gas Insert WARRANTY The Warranty Limited LifetimeConditions Exclusions See the inside back cover for details