Manuals / Southbend / Kitchen Appliance / Oven

Southbend STRG-3D, STRG-5D manual Electrical Connection

Models: STRG-3D STRG-5D

1 50

Download 50 pages 48.74 Kb

Page 19

Image 19

STRATOSTEAM COUNTERTOP STEAMER

INSTALLATION

STEP 6: ELECTRICAL CONNECTION

WARNING: THE STEAMER IS PROVIDED WITH A THREE-PRONG GROUNDING PLUG. THE OUTLET TO WHICH THIS PLUG IS CONNECTED MUST BE PROPERLY GROUNDED. IF THE RECEPTACLE IS NOT THE PROPER GROUNDING TYPE, CONTACT AN ELECTRICIAN. DO NOT REMOVE THE GROUNDING PRONG FROM THE PLUG.

Refer to the data plates located on the upper left front of the steamer and on the left side in the upper right corner.

For additional electrical information refer to the electrical diagram located inside the right hand removable panel in the upper left corner.

Figure 9

Electrical Connection

OWNER’S MANUAL 1185290

PAGE 19 OF 50

Page 19

Image 19

Southbend STRG-3D, STRG-5D manual Electrical Connection

Contents

StratoSteam Countertop Steamer Models STRG-3D and STRG-5DBURN HAZARD SAFETY PRECAUTIONSFIRE HAZARD FOR YOUR SAFETY DANGERLocation of Serial Plates INTRODUCTIONMINIMUM CLEARANCES FROM COMBUSTIBLE CONSTRUCTION SPECIFICATIONSMAXIMUM FILL CAPACITY 0.87 GALELECTRIC CABLE ENTRY HOLE CONNECTION ¼” COMPRESSION, COLD WATER PRESSURE 30 TO 60 PSITOTAL DISSOLVED SOLIDS TDS 60 PPM OR LESS HARDNESS 2 GRAINS 35 PPM OR LESS pH 7.0 toDRAIN REQUIREMENTS ELECTRICAL REQUIREMENTSGAS PRESSURE REQUIREMENTS WATER REQUIREMENTSPossible Causes and Solutions NOTICE WATER SPECIFICATIONOPERATION ProblemControl Lever TimerPower Light ThermometerPAGE 9 OF COOKING TIPSSUGGESTED COOKING TIMES DAILY CLEANING AND MAINTENANCE CLEANING & MAINTENANCESTAINLESS-STEEL SURFACES PERIODIC DE-LIMING AS NEEDEDPAGE 12 OF PAGE 13 OF INSTALLATIONAttach Legs IMMEDIATELY INSPECT FOR SHIPPING DAMAGESTEP 2D STACKING TWO STEAMERS Installation on CountertopSTEP 2B ATTACH TO COUNTERTOP STEP 2C MOUNTING ON CABINET BASESTEP 3 DRAIN CONNECTION Location of Connections and VentsWater Connection Water DrainSTEP 4 WATER CONNECTION STEP 5 GAS CONNECTION TESTING THE GAS SUPPLY PIPINGElectrical Connection STEP 9 SHUT-DOWN AND WIPE-CLEAN STEAMER STEP 7 CHECK THE INSTALLATIONSTEP 8 CHECK STEAMER OPERATION SERVICE Troubleshooting Flowchart, Procedure, or Wiring Diagram TROUBLESHOOTING FLOWCHARTS, PROCEDURES, AND WIRING DIAGRAMSHOW THE STEAMER OPERATES PAGE 23 OF How the Steamer Operatesvoltage 120, 208, 220, or Steamer Not Heating Up, “Power” Light Is Not LitDISCONNECT POWER AT CIRCUIT BREAKER DISCONNECT POWER AT CIRCUIT BREAKERIs water level at DISCONNECT POWER AT CIRCUIT BREAKERDISCONNECT POWER AT CIRCUIT BREAKER Check for loose or broken wires see wiring diagramDISCONNECT POWER AT CIRCUIT BREAKER Buzzer Does Not Come On When Timer Runs OutPAGE 26 OF PAGE 27 OF Hot Surface Ignitor Glows Red, But Burners Not OnHot Surface Ignitor Does Not Glow Red when operating, should drawIs there 24V from ignitor propane? Not All Burners IgniteIs gas pressure at least 4” WC for natural gas and at least 11” WC forvalve? Burner Lights But Goes Out Within a Few Secondsburners do not come on when SymptomPossible Cause Cure1. DISCONNECT POWER AT CIRCUIT BREAKER Power Switch Check1. DISCONNECT POWER AT CIRCUIT BREAKER Timer and Buzzer Check1. DISCONNECT POWER AT CIRCUIT BREAKER Door Switch CheckPAGE 34 OF High-Limit Thermostats Check 2. DISCONNECT POWER AT CIRCUIT BREAKERWater Solenoid Check 1. DISCONNECT POWER AT CIRCUIT BREAKERPAGE 36 OF PAGE 37 OF Wiring Diagram for 208/220/240 Volt and 115 Volt ModelsHIGH LIMIT TSTATS PARTS Parts DiagramStructural Parts Structural Parts See parts list on previous pagePAGE 40 OF NYLON WASHER, 1/4 X 1/2 X 1/8 Door Assembly PartsPIN, .250 DIA, SS, CAST LATCH STEAMER Door Switch PartsPAGE 42 OF 1-17 Control Panel PartsNot shown on drawing Quantity of part used may depend on model STRE-3D or SRTE-5D Burner Assemblies, Thermocouple, and Ignition ModuleIR BURNER ASSEMBLY, PROPANE BURNER BOX, STRATOSTEAM GASFITTING, 1/8 NPT X 1/4 CC STRAIGHT 1/4 M X 3/8 CC Water Train PartsPAGE 45 OF See parts list on Water-Train Partsprevious page PAGE 47 OF Cabinet Base PartsPAGE 48 OF Cabinet-Base PartsPAGE 49 OF STRATOSTEAM COUNTERTOP STEAMERStratoSteam Countertop Steamer Models STRG-3D and STRG-5D