Manuals / Southbend / Kitchen Appliance / Oven

Southbend STRG-3D, STRG-5D manual Cabinet Base Parts, PAGE 47 OF

Models: STRG-3D STRG-5D

1 50

Download 50 pages 48.74 Kb

Page 47

Image 47

STRATOSTEAM COUNTERTOP STEAMER

SERVICE

Cabinet Base Parts

See drawing on following page.

Key		Part Number	Qty	Description
1		1183993	2	PANEL, 24" SS DOOR
2		1183989	2	LINING, 24" SS DOOR
3		1183987	2	HANDLE, CATCH DOOR
*		1182637	2	CATCH, MAGNETIC, SGS
4		1183985	1	HINGE ASSEMBLY, UPPER LEFT
5		1183983	1	HINGE ASSEMBLY, UPPER RIGHT
6		1183984	1	HINGE ASEMBLY, LOWER RIGHT
*		1183986	1	HINGE ASSEMBLY, LOWER LEFT
7		1184527	1	COVER, 24" BASE BOTTOM
8		1185141	1	BODY SIDE, CAB SS OPEN LT
9		1185144	1	PANEL, TOP CABINET
10		1185143	1	BODY BACK, 24 CABINET
11		1185142	1	BODY SIDE, RT
12		1172650	4	LEG PAD (3/4 X 10 HOLE)
13		1146500	16	1/4 LOCK WASHER
14		1146201	16	1/4 X 30 X 3/4 HEX HEAD
15		1174260	1	LEG PACKAGE (set of four legs, not including bolts, leg pads, or lock washers)
*		1174262	1	EARTHQUAKE LEGS SS (set of four)
*	Not shown on drawing.

OWNER’S MANUAL 1185290

PAGE 47 OF 50

Page 47

Image 47

Contents

StratoSteam Countertop Steamer Models STRG-3D and STRG-5DBURN HAZARD SAFETY PRECAUTIONSFIRE HAZARD FOR YOUR SAFETY DANGERLocation of Serial Plates INTRODUCTIONMINIMUM CLEARANCES FROM COMBUSTIBLE CONSTRUCTION SPECIFICATIONSMAXIMUM FILL CAPACITY 0.87 GALELECTRIC CABLE ENTRY HOLE CONNECTION ¼” COMPRESSION, COLD WATER PRESSURE 30 TO 60 PSITOTAL DISSOLVED SOLIDS TDS 60 PPM OR LESS HARDNESS 2 GRAINS 35 PPM OR LESS pH 7.0 toDRAIN REQUIREMENTS ELECTRICAL REQUIREMENTSGAS PRESSURE REQUIREMENTS WATER REQUIREMENTSPossible Causes and Solutions NOTICE WATER SPECIFICATIONOPERATION ProblemControl Lever TimerPower Light ThermometerPAGE 9 OF COOKING TIPSSUGGESTED COOKING TIMES DAILY CLEANING AND MAINTENANCE CLEANING & MAINTENANCEPAGE 12 OF PERIODIC DE-LIMING AS NEEDEDSTAINLESS-STEEL SURFACES PAGE 13 OF INSTALLATIONAttach Legs IMMEDIATELY INSPECT FOR SHIPPING DAMAGESTEP 2D STACKING TWO STEAMERS Installation on CountertopSTEP 2B ATTACH TO COUNTERTOP STEP 2C MOUNTING ON CABINET BASESTEP 3 DRAIN CONNECTION Location of Connections and VentsSTEP 4 WATER CONNECTION Water DrainWater Connection STEP 5 GAS CONNECTION TESTING THE GAS SUPPLY PIPINGElectrical Connection STEP 8 CHECK STEAMER OPERATION STEP 7 CHECK THE INSTALLATIONSTEP 9 SHUT-DOWN AND WIPE-CLEAN STEAMER SERVICE HOW THE STEAMER OPERATES TROUBLESHOOTING FLOWCHARTS, PROCEDURES, AND WIRING DIAGRAMSTroubleshooting Flowchart, Procedure, or Wiring Diagram PAGE 23 OF How the Steamer Operatesvoltage 120, 208, 220, or Steamer Not Heating Up, “Power” Light Is Not LitDISCONNECT POWER AT CIRCUIT BREAKER DISCONNECT POWER AT CIRCUIT BREAKERIs water level at DISCONNECT POWER AT CIRCUIT BREAKERDISCONNECT POWER AT CIRCUIT BREAKER Check for loose or broken wires see wiring diagramPAGE 26 OF Buzzer Does Not Come On When Timer Runs OutDISCONNECT POWER AT CIRCUIT BREAKER PAGE 27 OF Hot Surface Ignitor Glows Red, But Burners Not OnIs there 24V from ignitor when operating, should drawHot Surface Ignitor Does Not Glow Red propane? Not All Burners IgniteIs gas pressure at least 4” WC for natural gas and at least 11” WC forvalve? Burner Lights But Goes Out Within a Few Secondsburners do not come on when SymptomPossible Cause Cure1. DISCONNECT POWER AT CIRCUIT BREAKER Power Switch Check1. DISCONNECT POWER AT CIRCUIT BREAKER Timer and Buzzer CheckPAGE 34 OF Door Switch Check1. DISCONNECT POWER AT CIRCUIT BREAKER High-Limit Thermostats Check 2. DISCONNECT POWER AT CIRCUIT BREAKERPAGE 36 OF 1. DISCONNECT POWER AT CIRCUIT BREAKERWater Solenoid Check HIGH LIMIT TSTATS Wiring Diagram for 208/220/240 Volt and 115 Volt ModelsPAGE 37 OF PARTS Parts DiagramStructural Parts PAGE 40 OF See parts list on previous pageStructural Parts NYLON WASHER, 1/4 X 1/2 X 1/8 Door Assembly PartsPAGE 42 OF Door Switch PartsPIN, .250 DIA, SS, CAST LATCH STEAMER Not shown on drawing Control Panel Parts1-17 Quantity of part used may depend on model STRE-3D or SRTE-5D Burner Assemblies, Thermocouple, and Ignition ModuleIR BURNER ASSEMBLY, PROPANE BURNER BOX, STRATOSTEAM GASPAGE 45 OF Water Train PartsFITTING, 1/8 NPT X 1/4 CC STRAIGHT 1/4 M X 3/8 CC previous page Water-Train PartsSee parts list on PAGE 47 OF Cabinet Base PartsPAGE 48 OF Cabinet-Base PartsPAGE 49 OF STRATOSTEAM COUNTERTOP STEAMERStratoSteam Countertop Steamer Models STRG-3D and STRG-5D