Five Star Sr200na, Sr200lp,, Sr333na, Sr333lp,, Sr400na, Sr400lp owner manual

Page 37

Pool Heater Electrical Schematic Ladder Diagram

LADDER DIAGRAM

HOT		120 VAC	NEUTRAL
		IGNITER
L1	S1	S2	L2
F1	F2	BLOWER

GND

120 VAC

CLASS II

TRANSFORMER

		24 VAC
	OPERATING
	CONTROL
		24 VAC
24 VAC
24V	LOGIC
	WATER	HI
	PRESSURE	LIMIT
	SWITCH	SWITCH

COM NO

GND

AIR

FLOW

SWITCH

TH

IND

VAL

AGS

SWITCH

GAS VALVE

STACK FLUE

THERMISTORSENSOR

SENSOR

NOTES:

1.) L1 L2 F1 F2

S2 GND IND

S1 24 VAC

VAL AND TH

ARE CONNECTED ON THE IGNITION MODULE.

2.)

3.)

PIN AND SOCKET CONNECTOR.

IF ANY OF THE ORIGINAL WIRES AS SUPPLIED WITH THE APPLIANCE MUST BE REPLACED, THEY MUST BE REPLACED WITH TYPE 105°C OR ITS EQUIVALENT.

37

Image 37

Contents Sta-Rite Pool/Spa Group Special Instructions to OwnerTo Consumer To InstallerSafety Instructions OWNER’S Operating Instructions Description of the HeaterSequence of Operation START-UP and OperationWhat to do if YOU Smell GAS SPA Temperature CautionOperating Instructions Operating Control To Turn OFF GAS to the ApplianceAfter START-UP Maintenance Instructions Care and MaintenancePutting the Heater Into Service Installation InstructionsOutdoor Installation Instructions Heater Clearances OutdoorInstallation in a Garage Or Utility Room Indoor Installation InstructionsControl Panel Indexing Heater Clearances IndoorCombustion and Ventilation AIR Supply Indoor Vent InstallationOutside Vent Cover Removal Metal Flue Collar Sta-Rite Part No Vertical Venting Negative PressureMin. Height Minimum Height Connecting Special GAS Vent to the HeaterRoof Pitch Above Roof Brand Manufacturer Material Type Sealant MinSpecial Gas Vent Vertical or Horizontal No. of 90 Elbows Water ConnectionsCool Water Water PipingWater Chemistry Water Flow RateModel Minimum Flow Maximum Flow 200 120 333 400 Chemical ValuesPressure Relief Valve Water Pressure SwitchConnect Gas Valve to End Cap Air Orifice Supplying Power to the Heater Pressure TestingElectrical Wiring GAS ConnectionsFuse FIREMAN’S Switch ConnectionMax Temperature Set Point Controls Maximum Temperature SET PointDoes red Service Initial TroubleshootingHeater LED come Start Heater Will Not Fire aContinue Heater Will Not Fire BHeater Will Not Fire C Heater Will Not Fire D Do not jumper a safety switch to remedy a failed switch Diagnostic LED’s AGS, AFS, HLS, PS, ThermistorSFS on Diagnostic LED’s SFSHeat Exchanger Troubleshooting Burner TroubleshootingRepair Parts are available from your Sta-Rite dealer 2692 Repair Parts Burner System Repair Parts Water System Repair Parts Electrical System Pool Heater Wiring Connection Diagram Pool Heater Electrical Schematic Ladder Diagram Page Page Warranty Registration Card