Subaru Robin Power Products RG4300IS, RG3200IS, RG2800I Engine does not start Start failure

Page 59

Engine does not start (Start failure)

Check the gasoline in the tank

Yes

Oil warning lamp turns on when the recoil is pulled

None

warning lamp is on

Add gasoline

Check the oil level

Low

Add oil (up to the rated volume)

No

Fuel cock is in the ON position

Yes

Gasoline leaks when the carburetor drain is loosened

No Open the cock

No Clean, change

	Good
Confirm of the oil sensor
E/g
GND	Tester
	Tester

Resistance

value≒0Ω

Change Oil sensor

Yes

the filter

No continuity

Check for

gasoline deterioration

Good

Remove the spark plug and check the electrode

Wet

	Deteriorated		Change			Change the Inverter unit
			gasoline
	Dry
	Dry		Blockage of the fuel passage or
			Blockage of the fuel passage or
			jets of carburotor

Attach the plug to the plug cap, and check for sparks by pulling the recoil starter

No or

poor sparks ・Check for dirty electrodes, or gap ・Check the connection of coupler,

high tension cord and spark plug cap

Good Sparks

Check the compression at the spark plug hole by pulling recoil starter

Poor compression

Valve clearance adjustment

– 56 –

Image 59

Contents Generators Page Contents STD SpecificationsModel RG2800i RG3200i RG4300i NGK BR6HSModel RG2800iS RG3200iS RG4300iS External View of Generator Open Frame Type General DescriptionRG4300i RG2800iS External View of Generator Sound Proof TypeRG3200iS / RG4300iS 50Hz-240V Control Panel50Hz-230V 60Hz-120VMulti Monitor Engine SwitchLocation of Serial Number and Production Number Alternator Range of Applications Incandescent lamp, heater, etc. with a power factorMercury lamps with a smaller power factor Appliances without any indication as to power consumption Cross Allowable Cable Voltage drops per 30 meters of cable Ammeter Measuring and Checking ProceduresMeasuring Instruments VoltmeterTachometer Circuit TesterMeager Tester Dr.RobinPartNumber388-47565-08 SpecificationsModel DC Output Measuring AC Output MeasuringControl Panel Measuring Insulation ResistanceStator RG2800i RG3200i RG4300i RG2800iS RG3200iS RG4300iS Output Wires4P Connector Checking Functional MembersAC Receptacles Diode RectifierChecking table for analogue circuit tester Checking table for degital circuit testerFloat Type OIL Sensor DC Circuit BreakerPart Number Part Name Shape Usage Disassembly and AssemblyPreparation and Precautions Special ToolsStarter Handle Disassembly ProceduresFuel PIPES, Fuel Strainer and Battery Cables Side Cover L and RControl Panel and Inverter Unit Grounding WireChoke Wire For electric start modelsRear Cover Wire BandFuel Tank and Fuel System Parts Fuel TankAutothrottle Coupler Wire HarnessInverter Unit Components Control BOX and Inverter UnitComponents and Control BOX Components Control Panel Control BOX Components RG2800i / RG3200i / RG2800iSControl BOX Components RG4300i / RG3200iS / RG4300iS Muffler Foam Rubber InsulatorsMuffler Cover AIR Cleaner and Carburetor Soundproof Type Engine BlockOpen Frame Type Through Bolt and Rotor Alternator Components Bottom Extension Plate Blower HousingRecoil Starter Flywheel Drive Shaft and FANFor SOUND-PROOF Models Reassembly ProceduresMount Rubbers Sound InsulatorTightening torque 40-60 Kgf ・cm 4.4 Ft ・lbs Blower HousingFlywheel FAN and Drive Shaft Tightening torque 8.0-10.0 N・m 80-100 kgf・cm 5.9-7.4 ft・lbsThrough Bolt thread in reverse direction Recoil StarterTightening torque 6.5-8.5 N・m 65-85 kgf・cm 6.3 ft・lbs Rear CoverInstallation of Engine Alternator Assembly Onto Frame Tightening torque 6.0-8.0 N・m 60-80 kgf・cm 5.9 ft・lbs AIR Cleaner BaseAIR Cleaner Element CarburetorMuffler Cover MufflerControl BOX and Inverter Unit Grounding WiresConnection of Wiring Harness Tightening torque 4.0-6.0 N・m 40-60 kgf・cm 4.4 ft・lbs Clamping of the Choke Cable and Ground WiresAuto Throttle Fuel TankMuffler Cover Rear Rear Cover UpperGround Wire Side Cover Recoil Starter HandleRecoil Starter Disassembly proceduresDisassembly is completed Assembly procedure Five turns in counter-clockwise When Checking items after assemblyNo output power or Low output Trouble ShootingImproper revolutions Electronic throttle Engine does not start Start failure RG2800i / RG3200i / RG2800iS 50Hz-230V Recoil starter model Wiring DiagramRelay AC receptacle Earth ground terminal RG2800i / RG3200i / RG2800iS 50Hz-240V Recoil starter modelEngine 240V Switch Fuse10A RG2800i / RG3200i / RG2800iS 60Hz-120V Recoil starter model Engine 120V SwitchDiode DC output Terminal Rectifier Coil Page Lively Blvd. Wood Dale, IL 60191 Phone 630-350-8200 Fax

Related manuals

Manual 42 pages 29.77 Kb