BSP5500L Generator
SPECIFICATIONS
Maximum Surge Watts | . .8,500 watts |
Continuous Wattage Capacity | . .5,500 watts |
Power Factor | . . . . . . . . .1.0 |
Rated Maximum Continuous AC Load Current: | |
At 120 Volts | . . .45.8 Amps |
At 240 Volts | . . .22.9 Amps |
Phase | |
Rated Frequency | . . . .60 Hertz |
Fuel Tank Capacity | 7 U.S. gallons |
Shipping Weight | . . . . 152 lbs. |
GENERAL MAINTENANCE RECOMMENDATIONS
The Owner/Operator is responsible for making sure that all periodic maintenance tasks are completed on a timely basis; that all discrepancies are corrected; and that the unit is kept clean and properly stored. Never operate a damaged or defective generator.
To Clean the Generator
CAUTION! Never insert any object or tool through the air cooling slots, even if the engine is not running.
•Use a damp cloth to wipe exterior surfaces clean.
•A soft bristle brush may be used to loosen caked on dirt or oil.
•A vacuum cleaner may be used to pick up loose dirt and debris.
•Low pressure air (not to exceed 25 psi) may be used to blow away dirt. Inspect cooling air slots and opening on generator.These openings must be kept clean and unobstructed.
STORAGE
The generator should be started at least once every seven days and allowed to run at least 30 minutes. If this cannot be done and you must store the unit for more than 30 days, use the following guidelines to prepare it for storage.
Engine Maintenance
See engine owner’s manual for instructions.
CAUTION! Avoid prolonged or repeated skin contact with used motor oil. Used motor oil has been shown to cause skin cancer in certain laboratory animals.Thoroughly wash exposed areas with soap and water.
KEEP OUT OF REACH OF CHILDREN. DON'T POLLUTE. CONSERVE RESOURCES. RETURN USED OIL TO COLLECTION CENTERS.
Generator Storage
•Clean the generator as outlined in “To Clean the Generator.”
•Check that cooling air slots and openings on generator are open and unobstructed.
CAUTION! Storage covers can be flammable. Do Not place a storage cover over a hot generator. Let the unit cool for a sufficient time before placing the cover on the unit.
Generator Maintenance
Generator maintenance consists of keeping the unit clean and dry. Operate and store the unit in a clean dry environment where it will not be exposed to excessive dust, dirt, moisture or any corrosive vapors. Cooling air slots in the generator must not become clogged with snow, leaves or any other foreign material.
NOTE: Do Not use a garden hose to clean generator. Water can enter engine fuel system and cause problems. In addition, if water enters generator through cooling air slots, some of the water will be retained in voids and cracks of the rotor and stator winding insulation.Water and dirt buildup on the generator internal windings will eventually decrease the insulation resistance of these windings.
Engine Storage
See engine owner’s manual for instructions.
Other Storage Tips
•To prevent gum from forming in fuel system or on essential carburetor parts, add fuel stabilizer into fuel tank and fill with fresh gasoline. Run the unit for several minutes to circulate the additive through the carburetor. The unit and fuel can then be stored for up to
24 months. Fuel stabilizer can be purchased locally.
•Do Not store gasoline from one season to another unless it has been treated as described above.
•Replace fuel container if it starts to rust. Rust and/or dirt in fuel can cause problems if it's used with this unit.
•Store in clean and dry area.
9