Xerox 2750 Passwords, Communications mode, Jog functions, Parameter viewing and modification

Page 36

Passwords

Certain menu items displayed on the control panel are password protected for the KEY OPERATORS and TECHNICIAN ONLY. Untrained persons adjusting parameters can cause a great deal of damage to the folder. For each of these, the user will be prompted to enter the password. Use the number 1 button (up) until the appropriate number is reached, then press the number 3 button (set/enter). You now have access until either of two events occurs: Power to the folder is cycled on/off; or, a 10 minute interval passes with the keypad in the operators fold selection (default) mode. In either event, the keypad will return to a locked state requiring re-entry of the password.

The Key Operator Password can be obtained from your service technician.

System Menu

Page 1

1:Communications mode

2:Infeed jog Fwd

3:Infeed Jog Rev

4:Parameters

Page 2

1:Device Test

2:Assign folds

3:Assign handfeeds

4:Recent errors

Page 3

1:Stack sensor

2:Quit

Jam clearance – drives infeed motor forward

Jam clearance – drives infeed motor in reverse

Substitutes for an LED. Displays the status of the photosensor at the tower exit: 1 = open (no paper present), 0 = covered (paper detected).

Communications mode

Page 1

1:NORMAL = Normal printer/folder communications

2:USE KEYPAD FOLDS = Overrides Controller fold selections, but maintains communications (e.g., for job recovery)

3:NONE = Serial port disconnected (comms OFF)

4:LOOPBACK TEST = Communications test

Page 2

1: Quit

Jog functions

These are accessible to the operator - no password required.

Parameter viewing and modification

Viewing - unrestricted access

Modification - technician only

2750 op#4 R3.doc 10-02

Page 4-2

Image 36

Contents PRINTFOLD Synergix Fold System Engineering Document Folder General information Synergix Fold SystemMain components of the Model 2750 Folder Power entry module / counter / communications port Operator’s control panelMain control panel Instant service access BridgeStacker/Handfeed Automatic document diversionTower in normal folding and bypass modes Manual feed slotAccordion folding overview Standard accordion fold packetType F bookfold packet Crossfolding overview Folds handle easier than Z-foldsKey facts about fold programs SEL = standard feed directionLEL = non-standard feed direction Width sensors at input end of bridge Main features of the 2750 folding system Options availableAfter installation Power entry panelModel 2750 Folder operator’s side Operator’s controls ½ x 11 C-folded packet, landscape style12 Z-folded packet, portrait style BkaZ ½ x 11 book-folded packet Z fold onlyFold Selection Host controller Start-upReset procedure Fold Selection StandaloneOn-line programs Hand feed programsManual document feeding Rear of diverter tower, showing stacker/off-line componentsTo begin hand feeding Hand feeding a documentExiting Handfeed Mode Jam conditions Clearing a jamBridge and Bridge Exit If the document is visibleRaising the bridge lid Unlocking the bridgeAccess to the tower TowerRaising the bridge Use the jog feature … Accordion FolderAccordion folder lid in raised position Opening the upper clam shellUsing the crank handle to rotate the drum Raising the drum faceplate shutterEjector springs on crank handle Crossfolder Crossfolder latchesUpper section of the crossfolder in raised position Crossfold Transfer Crossfold Pocket and Crossfold ExitCrossfolder rear panel Unhitching the accordion and cross folderInterlock Open Crank handle engaged in crossfold rollCrossfold pocket System Error Initial phase of the folding program Accordion FolderIn-feed and accordion folding components Panel measuring phase Drum reversal develops a loopCompletion of the first fold Starting the second fold Accordion fold compensating panelsDocument inversion CrossfolderFirst crossfold action Single crossfold mode Double crossfold modeOperator’s control panel System MenuPasswords Communications modeJog functions Parameter viewing and modificationAccessible only to the Key Operator and technician Device testRecent errors Activity countersSheets 1s 3 0 5 721p Synergix Fold System 40 & XES 2750 Series fold tables DescriptionAfnor Fold Banks Peco Fold MIXFold Bank 1 common European sizes Folder Error Messages Message Definition Location or type of error