Meco Bonza Deluxe Series, Bonza Series Leak Testing to be Performed in a WELL-VENTILATED Area

Page 21

STEP 13-LEAK TESTING (TO BE PERFORMED IN A WELL-VENTILATED AREA.)

·Perform a leak test before each use.

·Leak test must be performed in a well

ventilated area.

·Never perform a leak test on a grill while in use or hot.

·If you detect a gas leak that cannot be corrected

by

using the leak test procedures below, do not

use

the LP gas grill.

· Never smoke or have an open flame near the

grill

during a leak test.

·Insure Regulator Hose does not contact hot metal surfaces.

Supplies Needed for a Leak Test

Clean paint brush, water, and dishwashing liquid

How to perform a leak test

WARNING! Never use an open flame to test for gas leaks.

1)Mix one cup of water with one cup of dish washing liquid.

2)Confirm that all control knobs on the control panel

are

in the off position.

3)Remove control knobs and the three retaining screws at the bottom of the control panel.

4)Remove front control panel cover.

5)Open valve on LP gas cylinder (Turn counter- clockwise).

6)Check for leaks by brushing the soap solution on all

LP

gas connections and fittings. Make sure you

generously brush the seven locations with the

soap

solution, completely surrounding the connections

and

fittings (See diagram below.)

7)If “growing” bubbles appear on any of the connection points, then you have detected a gas leak. Immediately close the LP cylinder valve.

A)If leak appears at either end of hose and regulator

assembly, retighten the connection at the leak,

 

but

do not overtighten. (Note: Only hand tighten

 

at

coupling nut) (See Step 12 of Assembly

Ins

tructions) Repeat Leak Test.

 

B) If

the leak is coming from the LP gas cylinder,

 

from

the valves at the control knobs, or if the leak

 

cannot

be stopped, do not use the grill. Call Custome

rService at 1-800-251-7558.

8)Always turn off LP cylinder valve after performing a leak test. (Turn clockwise to a full stop.)

9)If your LP gas grill has been in storage or has not been used for a period of time, the burners should be maintained. See Burner Maintenance in the Care and Maintenance section of this manual.

21

1-MANIFOLD TUBE 2-REGULATOR HOSE FITTING

5, 6, 7 -GASKET SEAL AROUND MANIFOLD TUBE

5

6

3

3-THREADED FITTING 4-HOSE CONNECTION

4

21

Page 20 Page 22
Image 21
Page 20 Page 22
Contents AussieTM by For Your SafetyImportant Safeguards Do not attempt to correct the problem yourself Continuing use. See Before Using Your LP GasGrill Gas tion of cloggedMeco Corporation PART/DESCRIPTION BonzaBonza Deluxe Bonza Bonza Deluxe PART/ DescriptionDeluxe PART/ Description Bonza PART# QTYPART/ Description PART# QTY Bonza Item 1 or 3 Side Table X 1 3/8 Bolt 8pcs X 1 Bolt 8 pcs Wheel LEG/ Side Table Assembly ToolsTools Fixed LEG/SIDE Table AssemblyItem 9 8 pcs Item 8 8 pcs X 1 3/8Pcs LEG Brace Assembly ToolsX 1 Bolt Wood LEG X 2 Bolt WOO Bottom SHELF/LEG & Caster Assembly ToolsX 1 3/8 Bolt Metal X 1 Bolt Wood LEG 1/4 x 1 3/8 Bolt Metal LEGItem 22, 23 WHEEL/CYLINDER Bracket Assembly ToolsItem 26 4 pcs X 1/2 BoltAssembly Next Grill BODY/CART ASSEMBLY- Bonza & Bonza Deluxe ModelsRegulator Grill BODY/CART ASSEMBLY- Bonza ModelsAttach Decorative Privacy Panel to Cart ALL Models Install Burner ToolsNext Or 4 PCSFIG. F FIG. E#8 X 1/2 Screw 2pcs Install Bottom Body PANEL/GREASE TRAY- ALL ModelsAttach Handle and Heat Indicator to Hood Bonza Models Tools FIG. H Attach LP Cylinder to Grill ALL ModelsHow to perform a leak test Leak Testing to be Performed in a WELL-VENTILATED Area· Always check for gas leaks when you Connecting/ Disconnecting LP Gas Cylinder to GrillGAS, CYLINDER, Hose Regulator Information LP Gas CylinderBefore Using Your LP GAS Grill PrecautionsSelecting a Location Operating the LP GAS Grill LeakTestingPreparation Before Cooking Lighting the Grill Using the Integra Spark Ignition SystemDripping onto the cart and/or a grease fire Confirm each burner is lit before lighting another burnerCooking Mode LP GAS with Wood Chunks for Flavor Cooking Mode Charcoal onlyWood Chunks placed along left or right side of grill How to manually light your LP gas grill Manual Lighting of the GrillOpen hood Check Your Flame End of Cooking Session Care and MaintenanceGrill Cooking Roasting Hood CookingBurner Maintenance How to clean porcelain coated cast iron burnersPorcelain coated Cooking Surfaces Hood Cleaning the Grill Body Flavor ActivatorsBottom Panel/ Grease Tray Cleaning instructions for Charcoal and Wood chunk ash Preventive MaintenanceCaring for the Wood Cart Using a match Using the igniterBurners will not light Low flame or low heatFlare up Flames blow outPersistent grease fire Humming orImportant Notice Limited Warranty
Top Page Image Contents