Hearth and Home Technologies CARODG36I, CARDOG36IL, CARDOG42IL owner manual CAROLINA-42

Page 20

• The use of the top rear log is optional. It could cause	• Place right front log on the grate against the front of the
sooting in high-wind areas.	grate. Fit notches into the bottom of the log to position it
	as shown in Figure 8.6

Figure 8.15 Place Top Rear Log (optional)

CAROLINA-42

•Place the rear log on the shelf against the appliance rear wall. Position log as far back on the shelf as possible.

PUSH LOG TO BACK OF SHELF

Figure 8.4 Place Rear Log - Carolina-42

Figure 8.6 Place Right Front Log

•Place top left log on the indentations in the front left log and back log as shown in Figure 8.7.

•Place the left front log on the grate against the front of the grate. Fit notch in log to grate bar as shown below.

Figure 8.7 Place Top Left Log

•Place the top right log on indentations in the front right log and back log as shown in Figure 8.8 .

Notch against grate

Figure 8.5 Place Left Front Log	Figure 8.8 Place Top Right Log
	Figure 8.8 Place Top Right Log
Outdoor Lifestyles by Hearth & Home Technologies Inc. • Carolina • 4066-300 • Rev. Q • 7/11		20

Image 20

Contents CARODG36I CARODG36IL CARODG42I CARODG42IL Congratulations Listing Label Information/LocationTable of Contents Listing and Code Approvals Design and Installation Considerations If this ﬁreplace is to be installed within a wall, you mustGetting Started Tools and Supplies NeededStand-Alone Installation Built-in InstallationFraming and Clearances Select Appliance LocationClearances and Framing Dimensions CARODG36I, CARODG36IL 1448 mm MinimumNot be placed between Fireplace opening Ceiling/overhang Fireplace Appliance Preparation Securing and Leveling ApplianceFlashing Position, level, and secure the applianceControl Box Access Panel Gas InformationFuel Conversion Gas PressureValve Access Connect Incoming Gas Line to Manual Shutoff ValveIntelliFire Plus Pilot Ignition System Wiring Electrical InformationNine Hour Safety Shutdown Feature Control Module OperationInstalling the Optional Electric Kit Match holesWire the GFI receptacle as shown below Assemble the junction boxMantel Projections Facing MaterialPositioning the Logs Install Lava RockPilot Shield Notch against grate CAROLINA-42 Log and the top left log as shown in Figure Place Remaining Lava RockPlace left center log in the indentations on the front left Install Firescreen Insert RodGas Fireplace Safety Operating InstructionsYour Fireplace Screens Before Lighting FireplaceLighting the Appliance Final inspection byInitial Break-in Procedure After the Appliance is LitTroubleshooting IntelliFire Plus Ignition SystemTroubleshooting Symptom Possible Cause Corrective ActionMaintaining and Servicing the Appliance Risk of injury or property damage Before servicingMaintenance and Service Tasks Inspect Maintenance TasksAppliance Dimension Diagram Reference MaterialsCARODG42I, CARODG42IL Log Set Assembly Service Parts List#15 Non Combustible Board Part number list on followingStocked At DepotCARODG42I, CARODG42IL #14 Non Combustible BoardAdditional service part numbers appear on following Patch Kit, FiberTouch up Paint, Fiber Conversion Kit NG#15 Valve Assembly Warranty Outdoor Lifestyles Warranty 2108-975A 10/05/09Limitations of Liability Contact Information