Hearth and Home Technologies CARDOG42IL Patch Kit, Fiber, Touch up Paint, Fiber, Regulator LP

Page 35

CARODG42I, CARODG42IL

IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement				Stocked
parts for your appliance please provide model number and serial number. All parts listed				Stocked
in this manual may be ordered from an authorized dealer.				at Depot
ITEM	DESCRIPTION	COMMENTS	PART NUMBER
	Log Set Assembly		4067-017	Y
1	Log 1, Rear Log		4067-313
2	Log 2, Left Front		4067-314
3	Log 3, Right Front		4067-315
4	Log 4, Top Right		4067-316
5	Log 5, Top Left		4067-317
6	Log 6	Qty 3 req	4067-319
7	Standoff	Qty 2 req	4067-119
8	Burner/Grate Assembly NG		4067-019	Y
8	Burner/Grate Assembly LP		4067-018	Y
	Burner/Grate Assembly LP		4067-018	Y
8.1	Oriﬁce, NG		4067-154	Y
8.1	Oriﬁce, LP		4067-155	Y
	Oriﬁce, LP		4067-155	Y
8.2	Connector		4066-156
9	Screen Rod Assembly	Qty 2 req	4067-022	Y
9.1	Screen Rod	Qty 2 req	4067-305
9.2	Screen Assembly	Qty 2 req	4067-023	Y
10	Pilot Bracket		4067-112
11	Heat Shield		4067-113
12	Pilot Shield		4066-127
13	Control Box Assembly		4066-325	Y
14	Non-combustible Board
14.1	Top		4067-120
14.2	Left Side		4067-121
14.3	Back	Qty 2 req	4067-123
14.4	Right Side		4067-122
14.5	Lower Right		4066-126
14.6	Upper Front		4067-124
14.7	Front Sides	Qty 2 req	4067-125
	Bracket, Junction Box		4066-116
	Electric Conversion Kit to AC Power		ELEC-CARODG
	Patch Kit, Fiber		SRV-PACK
	Touch up Paint, Fiber		STRATFORD-KIT
	Conversion Kit NG		NGK-CARODG42	Y
	Conversion Kit LP		LPK-CARODG42	Y
	Pilot Oriﬁce NG		593-528	Y
	Pilot Oriﬁce LP		593-527	Y
	Regulator NG		NGK-DXV-50	Y
	Regulator LP		LPK-DXV-50	Y

Additional service part numbers appear on following page.

Outdoor Lifestyles by Hearth & Home Technologies Inc. • Carolina • 4066-300 • Rev. Q • 7/11

35

Image 35

Contents CARODG36I CARODG36IL CARODG42I CARODG42IL Listing Label Information/Location CongratulationsTable of Contents Listing and Code Approvals Tools and Supplies Needed Design and Installation ConsiderationsIf this ﬁreplace is to be installed within a wall, you must Getting StartedSelect Appliance Location Stand-Alone InstallationBuilt-in Installation Framing and Clearances1448 mm Minimum Clearances and Framing Dimensions CARODG36I, CARODG36ILNot be placed between Fireplace opening Ceiling/overhang Fireplace Position, level, and secure the appliance Appliance PreparationSecuring and Leveling Appliance FlashingGas Pressure Control Box Access PanelGas Information Fuel ConversionConnect Incoming Gas Line to Manual Shutoff Valve Valve AccessElectrical Information IntelliFire Plus Pilot Ignition System WiringControl Module Operation Nine Hour Safety Shutdown FeatureMatch holes Installing the Optional Electric KitAssemble the junction box Wire the GFI receptacle as shown belowFacing Material Mantel ProjectionsPositioning the Logs Install Lava RockPilot Shield Notch against grate CAROLINA-42 Log and the top left log as shown in Figure Place Remaining Lava RockPlace left center log in the indentations on the front left Insert Rod Install FirescreenBefore Lighting Fireplace Gas Fireplace SafetyOperating Instructions Your Fireplace ScreensFinal inspection by Lighting the ApplianceAfter the Appliance is Lit Initial Break-in ProcedureIntelliFire Plus Ignition System TroubleshootingSymptom Possible Cause Corrective Action TroubleshootingRisk of injury or property damage Before servicing Maintaining and Servicing the ApplianceInspect Maintenance Tasks Maintenance and Service TasksReference Materials Appliance Dimension DiagramCARODG42I, CARODG42IL Part number list on following Log Set AssemblyService Parts List #15 Non Combustible BoardAt Depot Stocked#14 Non Combustible Board CARODG42I, CARODG42ILConversion Kit NG Additional service part numbers appear on followingPatch Kit, Fiber Touch up Paint, Fiber#15 Valve Assembly Outdoor Lifestyles Warranty 2108-975A 10/05/09 WarrantyLimitations of Liability Contact Information