Weber 89559 manual Manually Lighting the Smoker Burner

26 OPERATING INSTRUCTIONS

MANUALLY LIGHTING THE SMOKER BURNER

WARNING: Check hose before each use of grill for nicks,

cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only Weber® authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com®.

1)Open the lid.

DANGER

Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flare-up which can cause serious bodily injury or death.

2)Open smoker box lid.

3)Fill smoker with water soaked wood chunks or chips.

4)Make sure all burner control knobs are turned off. (Push control knob in and turn clockwise to ensure that it is in the “OFF” position.)

WARNING: The burner control knobs must be in the “OFF” position before turning on the liquid propane cylinder tank valve. If they are not in the “OFF” position, when you turn on the LP cylinder valve, the “excess gas flow control” feature will

1

7

4

*The grill illustrated may have slight differences than the model purchased.

S-450

9

2 3 10

5

8

activate, limiting the flow of gas from the LP cylinder. If this should occur, turn off the LP cylinder valve and burner control knobs. Then start over.

DANGER

When the “excess gas flow control” feature is activated, a small amount of gas is still flowing to the burners. After turning off the cylinder and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light the grill. Failure to do so may result in an explosive flare-up, which can cause serious bodily injury or death.

5)Turn the cylinder on by turning the cylinder valve counter-clockwise.

6)Put a match in the match holder and strike the match.

7)Insert match holder and lit match down through cooking grates and Flavorizer® bars to ignite smoker burner.

48

10) Close smoker cover after wood starts to smolder and turn control knob to “LOW”.

TO EXTINGUISH

Push in and turn each burner control knob clockwise to “OFF” position. Turn gas supply off at the source.

WARNING: Do not lean over the open grill while lighting.

8)Push smoker burner control knob in and turn to “START/HI”.

9)Check that the burner is lit by looking down through the cooking grate.

DANGER

If the smoker burner does not light, turn the burner control knob to “OFF” and wait 5 minutes to let the gas clear before you try again.

WWW.WEBER.COM®