Craftsman 919.195411 owner manual Pressure reading

Page 25

 

PROBLEM

CAUSE

CORRECTION

Pressure reading

It is normal for "some"

If there is an excessive amount

on the outlet

pressure drop to occur.

of pressure drop when the

pressure gauge

 

accessory is used, adjust the

 

regulator as instructed in the

(if equipped)

 

 

Operation section.

drops when an

 

 

NOTE: Adjust the regulated

accessory is

 

 

pressure under flow conditions

used.

 

 

(while accesory is being used).

 

 

 

 

 

 

 

 

Air leak from

Possible defect in safety

Operate safety valve manually

 

safety valve.

valve.

by pulling on ring. If valve still

 

 

 

leaks, it should be replaced.

 

 

 

 

Compressor is

Prolonged excessive use

Decrease amount of air usage.

not supplying

of air.

Check the accessory air

enough air

Compressor is not large

to operate

enough for air requirement.

requirement. If it is higher than

accessories.

 

the SCFM or pressure supplied

 

 

 

by your air compressor, you

 

 

 

need a larger compressor.

 

 

Hole in hose.

Check and replace if required.

 

 

Check valve restricted.

Remove and clean, or replace.

 

 

Air leaks.

Tighten fittings.

 

 

Restricted air intake filter

Clean or replace air intake

 

 

 

filter. Do not operate the

 

 

 

air compressor with the

 

 

 

filter removed. Refer to the

 

 

 

"Air Filter" paragraph in the

 

 

 

"Maintenance" section.

 

 

Loose belt.

Loosen wingnut and then

 

 

 

tighten wingnut until it contacts

 

 

 

the washer, plus one turn.

 

 

 

 

Restricted air

Dirty air filter.

Clean or replace. See "Air

intake.

 

Filter" paragraph in the

 

 

 

"Maintenance" section.

 

 

 

Regulator knob

Damaged regulator.

Replace.

has continuous

 

 

air leak.

 

 

 

 

 

Regulator will

Damaged regulator.

Replace.

not shut off air

 

 

outlet.

 

 

 

 

 

 

25- ENG

A09713

Page 24 Page 26
Image 25
Page 24 Page 26
Contents Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A AIR CompressorTable of Contents Safety Guidelines Definitions Specification TableImportant Safety Instructions Model No 919.195411Always remain in attendance with HazardWhat Could Happen Attachments & AccessoriesRepairs attempted by unqualified Electricity. Like any other electricallyTo human consumption Your specific applicationHazard Warning Risk from Moving Parts Result in serious burns How To Prevent ItEquip area of operation with a fire extinguisher Keep children away from the air compressor at all timesAccessories AccessoriesGlossary Duty CycleContents of Carton AssemblyTools Required for Assembly To Install HandleTo Assemble Wheels Assemble Rubber FeetTo Add Oil To Pump To Add Oil InstallationLocation of the Air Compressor Grounding InstructionsVoltage and Circuit Protection Extension Cords120/240 Dual Voltage Motor Operation On/Auto/Off Switch Regulator Safety ValveKnow Your Air Compressor Quick ConnectBefore First Start-up How to Use Your Unit How to StopBreak-in Instructions Pressure Release Valve Check ValveBefore Each Start-Up How to StartCustomer Responsibilities MaintenanceTo Drain Tank To Check Safety ValveOil ChangingMotor Pulley/Flywheel Alignment Air Filter Inspection ReplacementAir Compressor Pump Intake and Exhaust Valves To Replace or Clean Check Valve Service and AdjustmentsPressure Relief Tube Nuts Nu ts Screwdriver Open position nothing is visibleMotor Pressure Switch ReplacementTo Replace Regulator Regulator Arrow To Replace BeltWing Nut Storage Problem Cause Correction TroubleshootingPressure reading Problem Cause Correction Problem Cause Correction Garantía ContenidoGarantía Total DE UN AÑO DEL Compresor DE Aire Modelo Nº 919.195411 Definiciones DE Normas DE SeguridadLesiones serias Resultar en lesiones menores o Moderadas Lesiones seriasGuarde Estas Instrucciones Instrucciones Importantes DE SeguridadCómo prevenirlo Qué puede occurrir Cómo prevenirlo Advertencia Riesgo de ExplosiónA09713 36- SP Advertencia Riesgo de Partes Móviles Qué puede occurrir Advertencia Riesgo de Quemaduras Qué puede occurrirAdvertencia Riesgo de Caída Qué puede occurrir Advertencia Riesgo de Operación Lasegura Qué puede occurrir Accesorios GlosarioCiclo DE Servicio AccesoriosContenido de la caja EnsambladoHerramientas necesarias para el ensamble DesempaqueEnsamble de las patas de caucho Ensamble de las ruedasPara agregar aceite a la bomba Para agregar aceite InstalaciónELÉCTRICO. Ante Enchufe Perno de Tomacorrientes Conexión aProtección del voltaje y del circuito Cables de extensión eléctricaMotor de doble voltaje 120/240 Conozca su compresor de aire OperaciónAntes del primer arranque Cómo utilizar su unidadInstrucciones para el asentamiento Válvula de Drenaje LaColoque el interruptor On/Auto/Off en la posición Off Cómo poner en marchaResponsabilidades del cliente MantenimientoRiesgo de Operación Cómo drenar el tanque Cómo verificar la válvula de seguridadAceite Polea y volante Alineación Filtro de Aire Inspección y reemplazoPara reemplazar o limpiar la válvula de retención Servicio Y AjustesPara volver a arrancar MotorPara reemplazar el regulador Interruptor de presión ReemplazoRegulador Flecha Cambio de la correaRiesgo de Operación Insegura Pueden ocurrir serias Tuerca mariposaAlmacenaje Problema Causa Corrección Guía DE Diagnóstico DE ProblemasNo perfore, suelde ni Alguna porque se debilitaráDesciende cuando Conexiones eléctricas sueltas 57- SP A09713 A09713 58- SP Repair Protection Agreements  Product replacement if your covered product cant be fixedContratos de Protección para Reparaciones Sears Parts and Repair Center MY-HOMECanada SU-HOGARSM
Top Page Image Contents