Quadra-Fire CASTILEI-MBK owner manual At Depot, Stocked

Page 45

	R Service Parts			Castile Insert

			Beginning Manufacturing Date: Jan 2011
				Ending Manufacturing Date: Active
IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement
					Stocked
parts for your appliance please provide model number and serial number. All parts listed					Stocked
in this manual may be ordered from an authorized dealer.					at Depot
ITEM	DESCRIPTION		COMMENTS	PART NUMBER
			Matte Black	7022-129BK
1	Top Cast - Must specify color		Porcelain	7022-129POR
			Powder Coat	7022-129PWD
2	Handle Cover Plate			SRV7022-144
3	Heat Shield, Top			SRV7022-143
4	Hinge Assembly, Top			7036-006P
5	Side Cast Hook			SRV7022-137
	Thumb Screw, 1/4-20 x 1/2		Pkg of 10	7000-617/10	Y
			Matte Black	414-0050BK
6	Side - Must specify color		Porcelain Color	414-0050POR
			Powder Coat	414-0050PWD
7	Glass Assembly, Side, 1 Piece - 5-7/8 in. W x 9 in. H		Interchangeable	414-5380	Y
	Gasket, Channel 1/8 x 1-1/4		10 Ft.	7000-377/10	Y
8	Backer, Side Window		Interchangeable	414-0280
9	Door Hinge Assembly			SRV7022-012
	Hinge, Door, Male			450-2810
10	Deﬂ ector, Bottom Airwash			413-0680
11	Bafﬂ e Assembly			7001-034	Y
12	Door Rope, 7/8”		8 Ft	842-2350
13	Brick, Left / Right, Cast			414-0270
14	Brick, Center, Cast			414-0260
15	Ash Pan Assembly			SRV414-6240
16	Plate, Ash Cleanout			7001-186
17	Magnet Round			SRV7000-140	Y
18	Bracket, Magnet			414-0930
19	Wire Harness			SRV414-1040	Y
20	Control Board 3 Speed			SRV7000-205	Y
	Fuse, 8 Amp, Control Box		Pkg of 1	812-3780	Y
	Fuse, 8 Amp, Control Box		Pkg of 10	812-3780/10	Y
			Pkg of 10	812-3780/10	Y
21	Face Hinge			SRV7022-138
			Matte Black	414-0040BK
22	Face - Must specify color		Porcelain Color	414-0040POR
			Powder Coat	414-0040PWD

Additional service part numbers appear on following page.

		01/11

January 19, 2011	7022-122	Page 45

Image 45

Contents Hot glass will cause burns Castile Pellet InsertWelcome to the Quadra-Fire Family Castile Pellet InsertTable of Contents Appliance Certiﬁcation BTU & Efﬁciency Speciﬁcations Listing and Code ApprovalsMobile Home Approved Glass SpeciﬁcationsAppliance Location Getting StartedDraft Castile Pellet Insert Locating Your Appliance & ChimneyNegative Pressure Minimum Vacuum Requirements 095Castile Pellet Insert Avoiding Smoke and Odors Negative Pressure, Shut-Down and Electrical Power FailureVent Conﬁgurations Outside AirInspect Appliance & Components Castile Pellet Insert Fire SafetyTools And Supplies Needed Pre-Burn Check ListAppliance Dimensions 3Dimensions and ClearancesMust be installed in a non-tapered enclosure Castile Pellet Insert Clearance To Combustibles, UL and ULCShown with Rear Vent and Outside Air Minimum Opening for Masonry and Factory-Built Fireplaces Masonry and Factory-Built FireplacesCastile Pellet Insert Floor Protection Prefabricated Metal ChimneyAltering the Factory-Built Fireplace Using a saws-all, cut out the ﬂoorVent Information Chimney and Exhaust ConnectionVenting Termination Requirements Minimum Vent for One Elbow Castile Pellet Insert Pellet Venting ChartsHorizontalHori tal Run,RunftFT MinimumVertical Vent for Three ElbowsFull Reline With Horizontal Outside Air 5Venting SystemsCastile Pellet Insert Full Reline With Vertical Outside Air 6Mobile Home Mobile Home InstallationOutside Air Kit Instructions 7Appliance Set-UpLeveling System Ance. Shown in Figures 18.1Adjustable Hearth Support Castile Pellet Insert Door Handle RemovalDoor Removal 20.7 Ex the sides into a bowed position before installing21.4 Surround & Trim Set, EconoSurround and Cast Trim Set Castile Pellet Insert Surround & Trim Set, Econo Cont’dPiece. Figure Shown in Figure .2 onTwo Piece Log Set Installation Castile Pellet Insert Thermostat Installation Operating Instructions Combustible/Non-Combustible MaterialsFuel Material and Fuel Storage Before Your First Fire Castile Pellet Insert General Operating InformationClear Space Thermostat Calls For HeatFire Characteristics Feed Rate Adjustment InstructionsCastile Pellet Insert Starting Your First Fire Castile Pellet Insert Ignition Cycles Frequently Asked QuestionsTurn down thermostat and let the appliance completely cool Page Symptom Possible Cause Corrective Action Maintaining & Servicing Your Appliance Quick Reference Maintenance ChartTypes of Fuel FrequencyCleaning Ash Drawer Cleaning Firepot with Cleaning Rod & Firepot Clean-Out ToolSee .1 on Ash Removal from Firebox Disposal of Ashes Frequency As neededCleaning Beneath Heat Exchanger Cleaning Heat Exchanger TubesCleaning the Glass Door Latch InspectionCleaning Exhaust Blower Requires No Lubrication Cleaning the HopperCleaning Convection Blower Requires No Lubrication Preparing Firebox for Non-Burn SeasonImmediate Attention and Cleaning is Required Castile Pellet Insert High Ash Fuel MaintenanceConvection Blower Replacement Castile Pellet Insert Combustion Blower ReplacementGlass Replacement Castile Pellet Insert Igniter ReplacementCastile Pellet Insert Bafﬂe & Brick Set Removal Re-installing Bafﬂe & Brick SetCastile Pellet Insert Re-installing Bafﬂe & Brick Set Cont’d Component Function Reference MaterialsWiring Schematic See .1 below Vacuum SwitchThermostat Snap Disc #1 Convection Blower 110FCastile Pellet Insert Component Locations Cleaning Rods & Heat Exchanger TubesService Parts Part number list on following pagesCastile Pellet Insert Stocked At Depot#23 Door Assembly #28 Feed AssemblyStocked at Depot #38 Firepot and Associted Parts StockedOptional Accessories SP-CSTLI5134 Description Comments Part Number Fasteners Service And Maintenance Log Service And Maintenance Log Cont’d Homeowner’s Notes Limited Lifetime Warranty Warranty Conditions Contact Information