Quadra-Fire CASTILEI-MBK owner manual Service And Maintenance Log

Page 51

R

Castile Pellet Insert

E. Service And Maintenance Log

Date of Service

Performed By

Description of Service

January 19, 2011

7022-122

Page 51

Image 51

Contents Hot glass will cause burns Castile Pellet InsertWelcome to the Quadra-Fire Family Castile Pellet InsertTable of Contents Glass Speciﬁcations Listing and Code ApprovalsAppliance Certiﬁcation BTU & Efﬁciency Speciﬁcations Mobile Home ApprovedAppliance Location Getting StartedMinimum Vacuum Requirements 095 Castile Pellet Insert Locating Your Appliance & ChimneyDraft Negative PressureOutside Air Negative Pressure, Shut-Down and Electrical Power FailureCastile Pellet Insert Avoiding Smoke and Odors Vent ConﬁgurationsPre-Burn Check List Castile Pellet Insert Fire SafetyInspect Appliance & Components Tools And Supplies NeededAppliance Dimensions 3Dimensions and ClearancesMust be installed in a non-tapered enclosure Castile Pellet Insert Clearance To Combustibles, UL and ULCShown with Rear Vent and Outside Air Prefabricated Metal Chimney Masonry and Factory-Built FireplacesMinimum Opening for Masonry and Factory-Built Fireplaces Castile Pellet Insert Floor ProtectionAltering the Factory-Built Fireplace Using a saws-all, cut out the ﬂoorVent Information Chimney and Exhaust ConnectionVenting Termination Requirements MinimumVertical Vent for Three Elbows Castile Pellet Insert Pellet Venting ChartsMinimum Vent for One Elbow HorizontalHori tal Run,RunftFTFull Reline With Horizontal Outside Air 5Venting SystemsCastile Pellet Insert Full Reline With Vertical Outside Air 6Mobile Home Mobile Home InstallationAnce. Shown in Figures 18.1 7Appliance Set-UpOutside Air Kit Instructions Leveling SystemAdjustable Hearth Support Castile Pellet Insert Door Handle RemovalDoor Removal 20.7 Ex the sides into a bowed position before installing21.4 Surround & Trim Set, EconoShown in Figure .2 on Castile Pellet Insert Surround & Trim Set, Econo Cont’dSurround and Cast Trim Set Piece. FigureTwo Piece Log Set Installation Castile Pellet Insert Thermostat Installation Operating Instructions Combustible/Non-Combustible MaterialsFuel Material and Fuel Storage Thermostat Calls For Heat Castile Pellet Insert General Operating InformationBefore Your First Fire Clear SpaceFire Characteristics Feed Rate Adjustment InstructionsCastile Pellet Insert Starting Your First Fire Castile Pellet Insert Ignition Cycles Frequently Asked QuestionsTurn down thermostat and let the appliance completely cool Page Symptom Possible Cause Corrective Action Frequency Quick Reference Maintenance ChartMaintaining & Servicing Your Appliance Types of FuelDisposal of Ashes Frequency As needed Cleaning Firepot with Cleaning Rod & Firepot Clean-Out ToolCleaning Ash Drawer See .1 on Ash Removal from FireboxDoor Latch Inspection Cleaning Heat Exchanger TubesCleaning Beneath Heat Exchanger Cleaning the GlassPreparing Firebox for Non-Burn Season Cleaning the HopperCleaning Exhaust Blower Requires No Lubrication Cleaning Convection Blower Requires No LubricationImmediate Attention and Cleaning is Required Castile Pellet Insert High Ash Fuel MaintenanceConvection Blower Replacement Castile Pellet Insert Combustion Blower ReplacementGlass Replacement Castile Pellet Insert Igniter ReplacementCastile Pellet Insert Bafﬂe & Brick Set Removal Re-installing Bafﬂe & Brick SetCastile Pellet Insert Re-installing Bafﬂe & Brick Set Cont’d Component Function Reference MaterialsSnap Disc #1 Convection Blower 110F Vacuum SwitchWiring Schematic See .1 below ThermostatCastile Pellet Insert Component Locations Cleaning Rods & Heat Exchanger TubesService Parts Part number list on following pagesCastile Pellet Insert Stocked At Depot#23 Door Assembly #28 Feed AssemblyStocked at Depot #38 Firepot and Associted Parts StockedOptional Accessories SP-CSTLI5134 Description Comments Part Number Fasteners Service And Maintenance Log Service And Maintenance Log Cont’d Homeowner’s Notes Limited Lifetime Warranty Warranty Conditions Contact Information