Lopi Yankee Bay Pellet Insert manual Installation into a Masonry Fireplace, Hint

Page 15

Installation1 5

Installation into a Masonry Fireplace

Vertical Cap	“L” Vent
	Cover Plate (non-combustible)
Storm Collar	Seal the cover
	Seal the cover
	plate with silicone.

	“L” Vent Flex
	Section
	HINT:
	Paint the interior of the
	fireplace with latex paint to
	prevent fireplace odors
	from entering the home.
	Outside air may be drawn
	from the ash cleanout.
Travis	Industries	4 0 5 0 5 0 9	1 0 0 - 0 1 1 4 5

Image 15

Contents

Yankee Bay Pellet Insert 2Introduction Introduction Important InformationTravis Industries 5 0 5 0 0 0 1 1 4 Table of Contents 4Safety Precautions Mobile Home Safety Precautions6Specifications Installation7 Hopper Extension Set-up 8InstallationRe-install the hopper walls following the directions below Installation90Installation Venting the Pellet Stove Installation12Installation Mobile Home RequirementsOutside Air used for combustion Too Much Air Baffle InstallationRestrictor Adjustment Not Enough AirSurround Panel & Circuit Board Installation 4InstallationHint Installation into a Masonry FireplaceInstallation into a Factory Built Metal 6InstallationStarting the Heater for the First Time Safety NoticeOperation1 Location of Controls8Operation Loading PelletsTwo Modes of Operation To Shut Down Manual ModeTo Adjust the Heat To StartAuto Mode To Adjust Room Temperature or Start the Stove0Operation Operation2 Adjusting the Fan Speed2Operation Make Sure Pellets are Not Piling Up Maintenance2Daily Maintenance whenever using the heater Inspect the Burn4Maintenance Cleaning the FirepotCheck Firepot for Clinkers Vacuum Hopper Bi-Weekly Maintenance or every 10 bags of pelletsClean the Heat Exchange Tubes Cleaning the Optional Plated SurfacesOpening The Door 6MaintenanceCheck Baffles, Ashbox, Ashpan, Dispose Ash If Necessary Clean the GlassSweep Ash Into Ashpan 8MaintenanceYearly Maintenance or every two tons Clean the Vent make sure the heater and vent is cool 0MaintenanceMaintenance3 Door SealDoor Alignment Adjusting the Door Hinge and Latch 2MaintenanceCheck for Air Leaks Around the Door, Glass, and Ashpan Replacement Parts4Normal Operating Sounds Serial No Safety LabelYears 1 & 2 Coverage Parts & Labor Limited 7 Year WarrantyThermostat Optional Equipment8Optional Equipment Remote ThermostatOptional Log ZC Kit 9 9 2 0 0 1 4 0Index